^ mw ft^^^ Mp^ m Ji
m^m'M
tM:§i}l^,MM.MM^-
W m- m
MM
a% •^■. "f'^V ^-
f^#^,.*^.
if '.y
#%.^:..^'*./^
'A'4 ^vWVtwOQCVANPitnar ' >
T FIGHT ENGIN
1
FRANCIS A, COLLINS
wnwriiiMiBiiiiumwWiirniiiiiMiiiomii nmni>tMfmiiMM)VKW<mrj)otico'J6
\ -^---^- '^^x
THE FIGHTING ENGINEERS
THE FIGHTING ENGINEERS
THE MINUTE MEN OF OUR INDUSTRIAL ARMY
BY FRANCIS A. COLLINS
Author of "The Air Man," "The Camera Man,'' etc
ILLUSTRATED WITH PHOTOGRAPHS
iin,yf^€M
NEW YORK THE CENTURY CO.
1918
Copyright, 1918, by The Cejs'tubt Co.
P%ihlished, June, 1918
r './•
TO
THE AMERICAN ENGINEERS ^ AT CAMBRAI
Of
CO
345459
CONTENTS
CHAPTER PAGE
I Railroad Building "Over There" . 3
II Destructive Engineering .... 29
III The Road and Quarry Regiments . 41
IV Forest and Farm Regiments ... 54 V Arms and the Automobile ... 75
VI The Famous iith Engineers . . . 99
VII The Man Behind THE Guns . . .115
VIII Modern Shells and Armor . . . i47
IX American Versatility 164
LIST OF ILLUSTRATIONS
PAGE
American engineers on the job . . Frontispiece
Officers of the Fighting Engineers .... 9
Unloading American locomotives at a French
port 10
Track work at the front 23
A short cut through a deserted French village 24
Placing a turntable on a narrow guage railroad 33
Narrow guage construction 33
Marine engineering 34
The Highway Regiment at work .... 47
Ruthless destruction of shade trees .... 48
The invaders despoiling a French front . . 61
Amputation after a gun shot wound ... 62
A man power pile driver 7^
Railroad devastation 7^
A trench digger in action .... .81
One of our 100,000 war motors 82
German efficiency in bridge destruction . . 91
An example of German bridge building . . 92
ILLUSTRATIONS
PAGE
With the forestry regiment . . ., ,., „, . 105
Building a bridge against time . ,., . . 106
Type of modern ordnance 123
Work of the "Busy Berthas" 124
A modern gun in action 141
Modern ordnance on caterpillar wheels . . 142
American foresters at work in France . . . 155
A wayside repair shop . . . . . . .156
A problem for the waterways engineers . . 165
Temporary bridge construction 166
Familiar American architecture in a French
forest 175
All that remains of a French forest ... 176
An example of destructive engineering . . . 185
After a "retreat to victory" . .. <., . ... . 186
THE FIGHTING ENGINEERS
THE FIGHTING ENGINEERS
We dug up husky mountains by the roots ;
We spanned the rushing torrent with a bridge ; We laid the rails to guide the steam-charged brutes
That fed the men and guns at Cambrai Ridge. We built a road through slush and soupy mud,
While dodging shells the German "minnies" sent; We did the Job and saw that it was good —
And then we heard another call — and went.
The pick and shovel dropped from every hand ;
We didn't even notice where they fell ; We crawled or climbed or ran in No Man's Land
To bring back tortured souls from worse than Hell. And then the Germans came — we had to fight ;
With something near to joy we grabbed the guns ; For this we'd waited many a day and night
To send our deadly greeting to the Huns.
With British Tommies we stood face to face
With Death — and counted it the Chance Of all — to be with them in that red place,
To live and fight and maybe die for France. So shot for shot and ball for ball we gave,
From trench and shell-hole till the fight was won ; Then we came back, each from his living grave —
Save those whose living fighting days were done.
So when the story of the war is told,
Let one small chapter tell our little tale. Say that we helped the thin first line to hold —
That when the Big Test came we did not fail. But do not call us "heroes" — do not give
For those who died "out there" your futile tears. But, smiling proudly, let their names still live
Upon the Roll — the Fighting Engineers !
H. Varley. Courtesy New York Times.
THE FIGHTING ENGINEERS
CHAPTER I
RAILROAD BUILDING "oVER THERE"
ON the declaration of war the call for volunteers for the engineering regi- ments found America admirably prepared. In organizing its industries to create, rather than to destroy, the country faced familiar problems. The lively dangers of the enter- prise served only to arouse enthusiasm. No draft was needed to fill, almost overnight, the ranks of nine regiments of engineers for the period of the war. Drawing upon our boundless resources in skilled workers, the Government has recruited at this writing an army of 115,000 men.
The Great War is preeminently a conflict of engineers. A locomotive may prove more
3
THE FIGHTING ENGINEERS
deadly than a battery, while the building of bridges may decide the issue of a campaign.
The fighting engineers often face greater perils than soldiers in other branches of the service. Theirs is in no sense a ''bullet-proof job." Their losses frequently exceed those of the artillery regiments, the fatalities in which are, in turn, greater in number than those in the aviation corps. When other troops cross an exposed position, for in- stance, they usually do so at the double-quick, and seek shelter as soon as possible. The engineers often find themselves under fire at a time when they must stick to their work until it is finished.
The men of the engineering regiments look like those in any other army service. They wear the same uniform and carry the usual arms and equipment. Their best fighting, however, is done with such complicated weapons as engines, batteries, and construc- tion tools. The engineers receive only such military drill as will give them greater mo- bility and better organization. After a lim- ited period of training in camp they are hur- ried directly to France, since their real fight-
4
RAILROAD BUILDING
ing ability, now so sorely needed, has long since been trained to its highest efficiency.
While the drilling of other troops was scarcely under way, America had put in the field complete regiments of railroad men, forestry workers, miners, electricians, bridge builders, — in short, representatives of all departments of constructive engineering. The call for volunteers met with an enthusi- astic response in such widely scattered cities as New York, Philadelphia, St. Louis, Chi- cago, Boston, Pittsburgh, Detroit, Atlanta, and San Francisco. In New York, for in- stance, there were men enough in line, when the recruiting office opened on the first day, to make up the required quota. Ten appli- cants offered their services for every one who could be chosen. It is significant that the leading engineering societies of the coun- try display ''service flags" plentifully sup- plied with stars.
No activity of the American engineers has made so profound an impression upon France as the actual work of the regiments of rail- road men. The most persistent publicity campaign could not have taught Europe in
5
THE FIGHTING ENGINEERS
a generation so much about American rail- road methods. The traveled Frenchman or Englishman, especially if he were an engi- neer, knew something of the progress in railroad building in America, but the gen- eral public in the land of our allies was not prepared, and has been taken completely by surprise.
When the first American locomotive reached France a large force of our engi- neers was on hand to welcome it. Many French railroad men and government engi- neers watched with lively interest the un- loading of the strange importation. As the parts were swung to the dock American workmen quickly assembled them, working with a celerity that amazed the observers. Another force of American railroad workers meanwhile hastily laid a section of track from the dock to the main line. Several days would have been required by the for- eign workmen to complete such a task, but in a few hours the Americans had finished both jobs, got up steam, and tooted a fare- well.
The American locomotive's trip across 6
RAILROAD BUILDING
France was in the nature of a triumphal procession. The unusual size and form of the engine naturally attracted great atten- tion, while its American flag served to identify the visitor and assure its welcome. Here, in the midst of the cities and fields of France, was a tangible proof of the arrival of American forces. With its bell and whistle going without interruption, the en- gine was rushed to the eastern boundary of France.
Its destination was a sector occupied by American troops. News of the approach of the locomotive from back home flashed from camp to camp, and when the familiar whistle and bell were heard in the distance the sol- diers lined the tracks to welcome an old friend. As the engine came to a standstill the men greeted it with somewhat tremu- lous cheers, crowding about it and patting its wheels affectionately.
The locomotive had approached very near the front lines, and an unexpected complica- tion followed its noisy greeting. Its Ameri- can crew had not learned that the ringing of a bell is the signal at the front for a gas-
7
THE FIGHTING ENGINEERS
attack. The French troops who heard the clanging bell drew their own conclusions, and lost no time in crawling into their sub- terranean cellars and shelters. Not a Frenchman was on hand to welcome the new-comer. The bell has been removed, to be put to other uses ; but the American loco- motive is still in active service.
The American engineers found the French railroads very different from their own. It is a great tribute to their skill that American methods have been so quickly adapted to strange conditions. The French operating system, for one thing, is left-handed; the tracks are not of standard gage, in our sense ; the rails are differently adjusted, and a new signal system had to be adopted. Add to these problems the fact that the engineers have to conduct their work by the medium of a foreign language, and the difficulties may be appreciated. Within a few days after their arrival, nevertheless, the Americans had taken hold of this highly complicated system and were operating without mishap.
Large supplies of American locomotives and rolling stock have been carried to
8
RAILROAD BUILDING
France, and these have been ingeniously adapted to the new conditions. The differ- ence in the width of the tracks was overcome by adjusting the wheels' carriages so that the railroad-beds would serve.
The method of building tracks in France was a new problem for the American engi- neer. The French rails are differently sup- ported with wedges to tighten them. Our rails, of course, lie directly on ties or metal tie-plates. The French rail-joints are placed opposite ea(;h other, instead of being stag- gered as at home. In France a railroad curve is built on a scale of meters of radius, while Americans calculate the degrees of curvature.
In taking over the French railroad-proj- ects, the American engineers were first obliged to study the existing French plans and redraw them all to a new scale. The French method of preparing blue-prints of the proposed work differs from our own; besides, such work must be done with the constant aid of interpreters, and here again great difficulty was encountered, since the in- terpreters were laymen who were not fa- il
THE FIGHTING ENGINEERS
miliar with technical engineering terms. Furthermore, all the French dimensions and quantities, which are measured by the metric system, had to be translated into familiar units of measurement.
The Americans, nevertheless, completed this preliminary work, and carried through immense railroad projects at a rate that as- tonished the French engineers. Despite all the difficulties they had to contend with, it is interesting to mention the fact that one of the projects entrusted to the Americans has been the construction of main-line tracks long enough to reach from New York to Chicago.
Much of the equipment has had to be standardized to fit new conditions abroad. In laying down standard-gage railroad tracks in France, a special type of eighty- pound American Railway Association rail was rolled for the purpose. The French standard gage is four feet, eight and eleven sixteenths inches, or 114 centimeters, while American track is four feet, eight and one half inches. The narrow track consisted of twenty-five-pound American Society of Civil
12
RAILROAD BUILDING
Engineers standard rails, laid one foot, eleven and five eighths inches, or sixty centi- meters, apart. For both types of rails the American engineers provide standard turn- outs, frogs, switches, and cross-overs, made interchangeable left or right. A light, port- able type of track is also generally employed, which may be laid very rapidly and bolted into position.
Much of the trackage has been laid down in the immediate vicinity of the great sea- port freight-terminals. Practically all the supplies required by our fighters abroad must be ferried across the Atlantic. To handle this immense freight, classification depots and warehouses had to be built and a vast system worked out for routing this material from the ships to the front.
The classification sheds are very long, with a width of fifty feet, and have eight-foot platforms. The most approved mechanical equipment for handling freight had to be de- signed, built at home, and rushed to France. The railroad construction work in these great regulating freight-yards is said to be the most efficient in France.
13
THE FIGHTING ENGINEERS
The port-docks are great rectangular basins, which presented a pecuHar problem to the American engineers. Parallel to the sides and ends of these basins three lines of tracks were laid, and cranes and loading der- ricks were installed. In planning all this construction, it was found that French tim- ber does not have the same supporting strength as American lumber, and the plans had to be corrected accordingly. Again, the French piles could not be had in lengths greater than forty-five feet.
In many instances the regular materials could not be found, and any makeshift was employed.
Then, too, when our railroad cars arrived in France it was found that the wheel-trucks would not pass over the French turntables, and an entirely new turntable system had to be designed and built. A thousand unex- pected difficulties had to be met, in order that a smooth, steady stream of traffic might flow across France to the front.
The organization of these vast enterprises has been carried out along characteristic American lines. A Director-General of
14
RAILROAD BUILDING
Transportation has been put at the head of the building and maintenance of roads. The completeness of the organization is indi- cated by the titles of the various officials, these including a Deputy-Manager of Rail- roads, a Superintendent of Supplies, a Su- perintendent of Equipment, a Superintend- ent of Quarries, a Bridge-Engineer, a Su- perintendent of Business Affairs, a General- Superintendent of Construction, and many division engineers. Each division is highly specialized.
Shortly after their arrival in France the American railroad men were set to work on the highly complicated problem of double- tracking several of the main lines. Every detail of the work was entrusted to them. Hundreds of miles of land had to be sur- veyed, the roadbeds and bridges had to be widened, and countless engineering prob- lems had to be solved. Such double-tracked lines have been built from several seaports, — across the entire width of France, — to the front, in order that the carrying capacity of the railroads may be doubled as quickly as possible.
15
THE FIGHTING ENGINEERS
American workers soon became familiar objects in many sections of France. The skill and expedition of these regiments have made as profound an impression upon the French engineers as upon the general public. In the progress of this work a unique record for speed in railroad building has been es- tablished in France, if not in the world. A section of standard-gage track, just five eighths of a mile in length, — a French unit of measurement, — was built and made ready for traffic in two hours and ten minutes.
As the fighting men push forward, the task of supplying millions of troops with food and ammunition has become unprece- dented. To this end the railroads are al- ways the vital element. The American en- gineers have been very active of late in the unheard-of-task of transporting a railroad bodily from England to France. Every rail, tie, and spike of this system was taken up, its proper position marked, and the immense bulk of material loaded on steamers. The equipment was complete to the last detail, including the engines, cars, signal-systems, and repair-shops.
i6
RAILROAD BUILDING
After braving the U-boats in the EngHsh Channel, the railroad fleet arrivel safely in port, when an even more complicated task had to be faced. Only trained railroad men could be entrusted v^ith the work. The problems involved made a special appeal to the American engineers. Without an amazingly efficient system the work would have fallen into hopeless confusion. With the aid of the newest labor-saving ma- chinery, the track-bed was prepared, the tracks were laid, the repair-shops established and manned, and trains were soon running in a foreign land on their accustomed schedule.
The engineering methods of generations have often been swept aside in an hour. To transport a cargo from London to Paris and beyond has been a complicated procedure. Such a cargo must be handled at least four times in transferring it from train to boat and again to train, with countless delays, due to the conflicting methods of two different countries. To-day a railroad car is loaded wdth ammunition at a factory in England and unloaded in France at a point convenient
17
THE FIGHTING ENGINEERS
to the firing-line. Without the pressure of war, so direct a method might not have been adopted for generations. The American railroad engineer trained to get results in the shortest possible time, is proving indis- pensable to France and England in the intro- duction of these radical reforms.
Great technical skill in railroading is re- quired to work out the new problems. The transportation methods of both countries must be thoroughly understood to the last detail before they can be coordinated. The British, French, and American engineers, working together, have mapped out entirely new systems of transportation. Under the crushing burden of the war the French rail- roads have badly run down. They are in need of men and equipment of every kind. The men who operate them are sorely needed at the front. It is a matter of national pride that our best engineering talent has been quickly recruited for the task of recon- struction.
The gap between the terminus of the regu- lar railroad lines and the trenches is often difficult to bridge. The ground may be con-
i8
RAILROAD BUILDING
tinuously under fire from the great siege- guns of the enemy's batteries. Since the battle-Hne is drawn without a break uphill and down dale for hundreds of miles, it often passes through rough country. The land back of the trenches is frequently broken by deep ravines or valleys, where or- dinary railroad construction would be diffi- cult to carry on and to defend. The en- emy's aeroplanes are constantly on the look- out for such targets.
A light, narrow-gage track, separated by only twenty-four inches, is commonly used for the railroads immediately back of the trenches. By using light timbers, or almost any makeshift for ties, several miles of such track are often laid overnight. The trains of supply cars are hauled either by steam- engines or by gasoline-motors ingeniously contrived from an automobile. When it is important that the trains be as noiseless as possible, horses and mules are used as motive power.
When very rough country is to be bridged, an ingenious cable railway, which may be thrown across a deep ravine in a few hours,
19
THE FIGHTING ENGINEERS
is often employed. A narrow bridge or walk is built, of lumber, and light cables are strung at the side. The wheels of the cars are grooved to fit these cables, so that a com- paratively heavy load may be moved by hand-power.
When the trench-railroads traverse spe- cially exposed country, tunnels are often dug as a protection against attack. The tracks are arched, covered with branches of trees, ingenious arrangements of boards, or strips of painted cloth for the purpose of deceiving the scouting air men. The most flimsy cov- ering, if the coloring is cleverly arranged, will suffice. The familiar routine of rail- roading often goes forward in these curious tunnels within sound, perhaps within range, of the firing-lines.
American railroad men have been espe- cially commended by the British officers for their work in the flooded districts near the front in Flanders. Until our men came it had been found impossible to establish rail- road connections in the inundated sections. The British troops in this region were com- pelled to wade through a morass, camping on
20
RAILROAD BUILDING
the slightly higher bits of ground. The railroads were usually covered with water as fast as they were built.
To drain off the land, — hundreds of square miles of it, — was obviously impos- sible, while filling-in would have required enormous labor. The American engineers solved this problem, and actually "floated a railroad" that keeps the advanced lines in continuous communication with the rear. The censor has not permitted any informa- tion in regard to this work to come through, — for such information would be highly valuable to the enemy, — other than the gen- eral statement that an ingenious application of hydraulics has been employed.
The fighting railroad engineers at present comprise three regiments for operation, five for constructive work, and one for motive and repair work. The Eleventh Engineers has been recruited largely in New York ; the Twelfth Engineers comes from St. Louis; The Fourteenth, which directs operation of railroads, hails from New England; the Nineteenth, composed of railroad shop-men, comes from western Pennsylvania. It is the
21
THE FIGHTING ENGINEERS
last regiment which has done such excellent work on the Paris-Orleans system. The Thirty-Fifth was organized at Camp Grant, Rockford, Illinois. Still other regiments have been raised in Chicago, on the Pacific Coast, and in the southwest. Each of these regiments includes iioo men and 33 officers. The work of our railroad regiments abroad has been greatly facilitated by un- limited American supplies. Until Novem- ber, 15, 1917, the orders for railroad equip- ment exceeded $70,000,000; since that date these figures have been greatly increased. The early orders for supplies included :
100,000 tons of steel.
3000 complete turnouts.
500,000 ties.
12,000 freight-cars.
600 field- and ballast-cars.
600 miles of telephone and telegraph wire.
The work of the Canadian engineers in France has attracted special attention. Little was known abroad of the railroad en- gineers in Canada. On their arrival, a com- pany of Canadians were assigned to a par-
22
(•-.' tp t *?,
Fji^^
RAILROAD BUILDING
ticularly difficult piece of railroad construc- tion, and a time far short of ordinary esti- mates was fixed for completing the work. It was not thought possible that the Cana- dians could do the work, at least not in any- thing approaching the time agreed upon. The workmen from oversea were handi- capped by an unfamiliar environment. But these men, fresh from a successful struggle with grades in the Canadian Rockies, found the task comparatively simple. The work was completed several days before the ex- piration of the time allotted them.
Perhaps the most striking feat of the Ca- nadian railroad men has been the transpor- tation of large sections of railroads with their equipment, bodily from Canada to France. The Canadians found that they could spare many of the side-tracks from their railroad systems. To build so much track and equipment would have taken time, and time was a valuable commodity. Miles of track were quickly taken up, carried to the eastern seaports, loaded on shipboard, and carried to France. Within a few days after their arrival the tracks were actually doing 25
THE FIGHTING ENGINEERS
invaluable service in putting through troops and ammunition-trains from the seacoast to the front. To borrow a railroad from a neighbor is a unique request, especially when he lives more than three thousand miles over- sea.
All locomotives used near the front are painted a battleship gray, to render them as inconspicuous as possible. The American locomotives now employed in France are not our most powerful type, although far out- classing the European models. A standard locomotive has been selected for this work which weighs 166,400 pounds, or 275,000 pounds with its tender. It is the familiar eight-coupled driver-type, with two-wheeled pony-truck in front, and will haul sixty fully loaded freight-cars.
The biggest order for freight-cars yet re- ceived called for 13,000 cars of the flat, gon- dola, box, and other types. American cars used on French tracks are considerably longer than the French type. The latter has a capacity of twenty tons, while the Ameri- can car can carry thirty-five tons. They are mounted on two four-wheeled arch-bar
26
RAILROAD BUILDING
trucks, measure thirty-six feet in length, and weigh 32,000 pounds. American engineers have studied the problem carefully and have designed cars for this service that combine the best American and European features. One of the most useful pieces of machinery sent to France is a powerful steam-shovel, mounted on a caterpillar tractor, which is proving invaluable in railroad construction.
The distinguished personnel of the rail- road regiments is a guarantee of their high efficiency. America is lending her best talent to the service of France. The or- ganization and development of the railroad regiments is in charge of Mr. Samuel Felton, president of the Chicago Great Western Rail- road. In 19 1 6 Mr. Felton was selected to advise the United States Army in the Mexi- can campaign. American railroad opera- tions in France are in charge of Brigadier- General W. W. Atterbury, one of the operating vice-presidents of the Pennsyl- vania Railroad system. Prominent in the work are such well-known railroad men as Brigadier-General McKistry and Colonel G. M. Hoffman.
^7
.THE FIGHTING ENGINEERS
When the history of the American engi- neering regiments in France comes to be written, one of their achievements, which has hitherto passed uncited, will doubtless take a high place. During the Allied ad- vance at Cambrai, American engineers quickly extended their tracks far behind the enemy's trenches. In the forward rush they suddenly came upon a German railroad that had been left untouched in the panic of re- treat. The challenge was instantly accepted by the Americans, who connected their own line with the German system, so that trains could pass from the Allied line to the former German railroad without interruption. Our engineers laid altogether eight miles of track on the heels of the advancing column. By British officers this work has been com- mended as the most daring piece of construc- tion in the war.
The American railroad men have the credit, therefore, of building the first con- necting link in the service between Paris and Berlin since the outbreak of the war, al- though the schedule of trains remains to be adjusted.
28
CHAPTER II
DESTRUCTIVE ENGINEERING
IN no Other war have such scientific en- gineering methods been employed in purely destructive work. New standards for ruthlessness have been established. The enemy's engineers have brought techni- cal training and wide experience to the task, and have applied the most ingenious effi- ciency to the work of devastation. It has been commonly supposed that the methods of the Romans in destroying Carthage had set a perpetual standard; but their work now appears primitive and unscientific.
The destruction of a railroad is an espe- cially difficult problem for the engineers of an invading army. In a familiar picture of the Civil War troops are shown prying rails from the ties, heating and bending them into grotesque shapes. The fighting engineers of a modern army, with the latest tools and 29
THE FIGHTING ENGINEERS
experience at their command, could repair such damage in a few hours. To destroy miles of track so that they could not be again utilized would involve enormous labor.
During General Hindenberg's operations in Galicia hundreds of miles of track were destroyed by an entirely new method. Sol- diers attached dynamite-cartridges to the fish-plates of the tracks, hundreds of men doing the work at top speed. When the dynamite was exploded, every plate and rail was either shattered or badly bent, thus put- ting the system entirely out of commission.
When the same engineers had more time to work, their program was varied. The Russian railroads are built with a much wider gage than those in Germany, and the engineers with the armies invading Galicia were quick to profit by it. The ties were taken up and sawed, so that they would barely serve for the German gage of tracks. The roadbed could thus be utilized by the Germans, and on their retreat would be found useless for the purposes of the Rus- sian railroads. The Germans make a prac- tice of destroying all railroad buildings, such
30
DESTRUCTIVE ENGINEERING
as repair-shops, round-houses, tram-sheds, and stations.
The destruction of bridges has also become a scientific problem. In the early days of the war bridges were mutilated by the simple expedient of breaking them in the middle. The central span would be dynamited, leav- ing a gap in the structure, when the work was considered complete. As the invaders retreated, the engineers found little difficulty, however, in patching up these structures, sometimes in a few hours. They would build up a pier, — often with light scaffolding, — and mend the gap so that troops, or even trains, would soon be passing over them. Profiting by these mistakes, the engineers of the invading army thereafter made a much more thorough job of bridges by tear- ing the frames apart until restoration was impossible.
The long tunnels, hewn often from solid rock, offered still another problem to the en- gineers of destruction. New methods had to be devised. In previous wars armies that have occupied land containing tunnels have respected these works which represent so 31
THE FIGHTING ENGINEERS
much labor and which play so important a part in industrial life. In former times the lust for destruction was not so highly de- veloped as at present. German engineers, however, do not content themselves with destroying the tracks or roadbeds of tunnels, but drill deep into the rock and blast away the entrance, until the passages are com- pletely blocked and can only be cleared at great cost of labor and time.
The German engineers have also applied characteristic methods of efficiency in cutting down the forests of Belgium and Northern France and in transporting them to Ger- many. The most modern type of sawmills and machinery for cutting and hauling logs have been brought from Germany. The logs are stripped of their bark, which is util- ized, so that no byproduct shall go to waste. When lumber is needed in any section near the forests, sawmills have been established, in order that the finished products can be prepared without loss of time.
To "spike a gun" has long been an ac- cepted synonym for crippling it. Histories of battles abound in stories of daring men
32
^ ys-<;: •«t^«>«^5^
Narrow gauge construction
Placing a turntable on a narrow gauge railroad
DESTRUCTIVE ENGINEERING
who have rushed upon an enemy's gun, forced a bayonet into the bore, and thus de- stroyed its usefulness, perhaps at the cost of their own Hves. The great modern pieces of ordnance are proof against such attacks. The old-fashioned cannon of cast-iron or bronze might be reduced to junk by blows of a sledge-hammer or a charge of powder. The strength of a modern gun, however, is proof against such attacks. But the mech- anism for loading modern guns and mov- ing them into position is delicate, and the complicated machinery may be put out of commission by a few blows directed with scientific certainty.
The technical methods employed in mod- ern range-finding have been made an excuse for immense destruction. Many great buildings, even whole towns that would have been spared in past wars, have been attacked, because they aided the enemy in directing artillery fire. The success of a shot from one of the great modern cannon is not due so much to the man behind the gun as to the man behind the telescopic sight. By de- stroying towers, or positions from which
35
THE FIGHTING ENGINEERS
such observations may be made, the effective- ness of artillery may often be greatly re- duced. A problem new to international law- has thus been raised in the present conflict.
It is frequently found necessary to sacri- fice valuable property, belonging to loyal citi- zens, in order to facilitate artillery fire or to gain some purely technical advantage. During the early days of the war, when the German advance through Belgium men- aced Paris, a considerable section of the city was marked for destruction, in order to give free range for the great batteries brought up for its defense. Besides, in the event of the enemy's advance to this point, the buildings would afford valuable shelter. Here was a problem for the technical engineer. A large force of men was engaged in this work, and rows of buildings were scientifically demol- ished. Explosions of the blasts used to re- duce them were distinctly heard on the inner boulevards of Paris.
A special tribute should be paid to the Frenchman who cheerfully sacrificed his chateau in Northern France, so as to assist the artillery fire of a French battery. The
36
DESTRUCTIVE ENGINEERING
ancient building, surrounded by gardens, was shown to be in the way. The owner at once agreed to make the sacrifice; and he cahiily watched the French guns reduce his ancestral home to ruins.
A striking parallel might be drawn be- tween the methods employed by the Romans in devastating Carthage and those employed by the invaders of modern France. The scientific destruction of this rich, fertile country has been complete in every detail. When the enemy's forces retreat, nothing is left that the returning population may utilize in restoring their land to normal con- ditions. The homes in villages, for example, are reduced to piles of debris. Trained en- gineers first inspect the ground and deter- mine how dynamite may be exploded to re- duce the walls with the least possible waste of energy. Bridges are damaged beyond hope of repair by men skilled in bridge con- struction; roadways are ploughed up; shell- fire has pitted much of this country with craters, while the intricate systems of trenches have chopped up the once fertile fields.
37
345459
THE FIGHTING ENGINEERS
Engineers who have visited these scien- tifically devastated regions differ v^idely as to the length of time necessary to bring this land back to its original condition. Some have thought that a generation w^ould be re- quired, while others have been more hope- ful. Meanwhile the problem of restoration has been attacked with an engineering skill and efficiency equal to that of the invaders. Portable cottages are built wholesale. They are then taken apart, to be set up with all possible despatch when the opportunity comes to reoccupy the relinquished territory. An army of workers has been recruited for this work for which much of the service is volunteered.
In Northern France many of the roads that were the pride of the country have been found hopelessly mutilated by the enemy's engineers. The work has evidently been done by experts in road engineering, so that it would be easier to build a road in a new land than to attempt to mend these old road- ways. To work such destruction by hand would require an immense expenditure of time and labor; so, with characteristic effi-
38
DESTRUCTIVE ENGINEERING
ciency, massive power-machines have been employed by the enemy, machines that tear up the roadbed and scatter it, while keeping up a slow but steady pace.
The work of directing the water-courses and flooding the country whenever possible has evidently been carried out by expert hy- draulic engineers. A dam is thrown across a stream, and, when necessary, the water is even siphoned to a new level. Great tracts of land are thus placed under water, and these tracts have to be drained at great ex- pense before the territory can be reclaimed. These engineers often show great ingenuity in diverting the streams in such a way that sand will be washed over the fertile soil, thus rendering it useless to the farmers for a long period to come.
Since France is covered with an intricate network of canals, the enemy's engineers have found an unusual opportunity for sci- entific destruction. In time of peace a great fleet of canal-boats can navigate from one end of France to the other. The destruction of these waterways will cripple the interior commerce of France for years to come. A 39
THE FIGHTING ENGINEERS
favorite method of the invaders is to con- struct dams across the canals and so flood the surrounding country. In other places great sections of the banks are torn away by ex- ploding mines, so that when the country is reoccupied by the French the waterways cannot be used without rebuilding them.
One of the most wanton tricks of the retreating Germans is to leave a watch hang- ing in plain view in a deserted home. The watch is electrically connected with a mine, so that the first person who touches it is probably instantly killed in the explosion that follows. No possible military advan- tage is gained by this practice.
The condition of these reoccupied cities has been vividly pictured by a member of the nth Engineers in a recent letter from the front. He writes:
Visited a large French city the other day, which the Germans occupied, but which was later recap- tured by the French. No human being could imag- ine the destruction that has been wrought there. Among the thousands of houses, there is not a single one that could be lived in. Most of them are beaten to dust, churches and everything else.
40
CHAPTER III.
THE ROAD AND QUARRY REGIMENTS
FRANCE, in proportion to its area, has an immense mileage of roads, which naturally play a vital part in military opera- tions. In many sections of that country there is an average of one mile of road to every one and a half square miles of land. Enormous labor is involved in keeping these roads open for war traffic, and American engineers have tackled this problem with characteristic vigor.
The Road Building and Quarry Regiment, which was organized especially for such work, contains engineers experienced in road building under a great variety of conditions. The regiment carried to France a large con- structive plant, with much labor-saving ma- chinery, new to Europe, to facilitate the work.
These American engineers first made an 41
THE FIGHTING ENGINEERS
exhaustive study of the resources of the French quarries. Two men were selected to investigate. One was formerly prominent in the quarry business on the Pacific Coast, and the other was formerly the representa- tive of a large machinery manufacturing company. In their tour of inspection they covered nine hundred miles by automobile, visiting the principal quarries of France. The data thus gathered made it possible to accurately gage the resources of the quarries and at the same time to suggest what ma- chinery would be required.
It was found that the French method of quarrying calls for little use of the modern mechanical equipment common in America. According to American standards of effi- ciency there is an immense loss, due to the general use of hand-labor. It is impossible at present to find the proper mechanical equipment in France, and such machinery will have to be imported from America.
To begin with, most of the drilling in the
French quarries is done laboriously by hand.
The rate of drilling is said to be only from
one to one and a half meters per man a day.
42
ROAD AND QUARRY REGIMENTS
The drill-holes are usually about eight feet in depth. As a rule, the rock encountered is a soft limestone, with layers of clay. When the American steam-driven jackham- mer-drills get to work, the output will doubt- less be enormously increased.
After a blast the rock is usually broken by hand. The hammer used for this work is small, and the handle has been compared by Americans to a light cane. The stone- crushers used in some quarries are small and ineffective, compared with the American machines. Great improvement is also pos- sible in the use of power in driving these machines. The cars used for carrying stone are usually loaded by hand. The plans of the engineers of the Quarry Regi- ment include the general use of modern American stone-drilling and stone-crushing machinery, new methods of handling and storing the stone, and greater efficiency in loading the cars.
One of the first problems in such construc- tion is to build roads as free as possible from dust, since the dust-clouds quickly attract the enemy's fire. The slow, laborious work of 43
THE FIGHTING ENGINEERS
road-construction must often be carried on very close to the front, and the casualty rate is high. The problem is rendered extremely difficult by the unprecedented burdens the modern military road must support. It is often impossible, moreover, to get the best materials for road-building, and ingenious shifts must be employed. Again, ordinary road-building machinery cannot be employed near the front. A puff of smoke from a steam-roller, or the steam from its exhaust, is likely to attract a devastating fire from some German battery.
It was soon found that the limestone used in France for road-making was so soft that it clogged the American stone-crushers; but this was obviated by designing a special jaw for crushing it. American engineers have learned to like the soft limestone, since it compacts easily and thus facilitates the work. The familiar macadam road is found to stand up best under the enormous strain of war traffic, but even the best roadbed requires constant mending. It has been difficult to find the trap-rock commonly used in Amer- ica, but in the vicinity of the industrial cen-
44
ROAD AND QUARRY REGIMENTS
ters there is abundance of slag. The road- builders are constantly experimenting with new materials and new constructive methods, and this war experience is proving invalu- able.
A large force of American engineers and workmen has set to work to widen the French roads. These men find the main roads sufficiently wide, but many of the road- ways are only eighteen feet in width, and these are to be increased to thirty-four feet. An immense amount of labor is, of course, involved in this work.
The existing drainage-system must be re- adjusted, bridges must be widened, and scores of such problems solved, without in- terrupting traffic for an hour. The main military roads must be constructed with all the skill known to such engineering. A weight of thirty tons is commonly carried on a four-foot wheel-base, while eighteen tons of artillery are often supported by a single axle. The tanks are kept off the roads as much as possible, and when they have to be used a road-mending crew always follows to repair the resulting damage. The 45
THE FIGHTING ENGINEERS
weight of the tanks also worries the builders of wooden bridges.
The regulation of road-traffic on crowded thoroughfares is always difficult; but the problem is immensely complicated near the front. A greater number of motors often pass a given point near the front than are to be seen on Broadway or Fifth Avenue dur- ing the rush hours. Accidents are common, but the road must be kept clear at all costs. This dense stream of traffic must also be hur- ried forward at night, without slackening its pace and practically without lights, lest they attract the enemy's attention.
War traffic is regulated by military ''traf- fic cops," stationed at regular intervals. By day the traffic men signal with three flags, — red, green, and white, — and by night they use small lanterns of the same colors. The white signal, day or night, means "all clear," the green signal is to slow down traffic, and the red is to bring all traffic to a stop. When artillery or infantry wishes to pass, the road is completely cleared for them without a moment's delay.
It is so important that all lights be con- 46
ROAD AND QUARRY REGIMENTS
cealed at night that the immense traffic is compelled to find its way in the dark. To keep this traffic on the straight way a series of whitewashed pickets are driven at inter- vals of ten feet along the roadside. One of the favorite diversions of the German air- men is to locate a crowded military roadway and, flying low, to rake the line of ammuni- tion-trucks with their machine-guns, in the hope of causing an explosion.
As the road-builders approach the front, their work becomes increasingly difficult. The ground is often a succession of shell- craters, where no ordinary road could be built without an immense amount of grad- ing; and neither time or money can be spared for such work. In such cases they build a very serviceable plank road. The timbers for this road are prepared of a standard size, measuring five by nine inches, with a length of nine feet. The lumber is adjusted to the irregularities of the land, the planks are spiked firmly together. This plank road is quickly laid and serves very well for one- way traffic.
The Road-Building Regiment has also 49
THE FIGHTING ENGINEERS
performed invaluable service in constructing miles of foot-bridges throughout the devas- tated regions of Northern France and Bel- gium. Great tracts of country have been so cut up by shell-craters or abandoned trenches as to be practically impassable.
The Americans have introduced a type of foot-bridge familiar in marshy tracts in the United States, by driving stakes into the ground and constructing a narrow board- walk a foot or more above the ground or water, as the case may be. Its construction is simple and inexpensive, and it clears the way for the passage of light wheelbarrows, small wagons, and foot-traffic.
Volumes might be filled with descriptions of the engagements of the road-builders. For instance, it is the boast of the men of the Road-Building Regiment that when they had been enlisted but seven months they had seen four months' service at the front.
The following quotation from a letter from one of the officers gives an excellent picture of their work. He writes:
50
ROAD AND QUARRY REGIMENTS
The day after Thanksgiving we left camp at six o'clock. We were running parallel with the front line and about one mile and one half from it.
There was very heavy shelling, — in fact, quite a barrage was breaking just over the hill between us and the front line ; but, as we had been more or less under shell-fire during the past weeks, we did not think it was anything unusual. We had just set nicely to work, spread along nearly a half-mile, when the barrage lifted over the hill. We had to get out then as quickly as we could, although we had not yet any idea that the Boche was coming over.
Lieutenant Holstrom had to go through the bar- rage to reach his detail. Lieutenant Cone went in one direction and I went in the other, to get all the men away. In fact, we did get every man away who was in sight ; but a number of men had jumped into dugouts for shelter from the shell-fire, and we could not see them.
When I had brought every man away from my vicinity, I started across a field, hurrying the men ahead of me to a sunken road several hundred yards away. Cone was one hundred yards to my left and slightly in the rear, hurrying along the men he had gone for. We were all just ahead of the bar- rage.
When I reached the sunken road I got the men into dugouts there, and looked back over the edge
51
THE FIGHTING ENGINEERS
of the road. There was Cone coming along, with his head, face, neck, — everything, — covered with blood. He had been caught by a shell-burst ahead of the main barrage, and the shell-bursts of the bar- rage were now getting thick about him and over the sunken road. I hurried out and helped him in, with two of his men who had come in with him. The shell-fragment had gone in one side of his steel hat and out the other, giving him a bad scalp- wound on top of his head, but not injuring the skull.
He said that Sergeant Haley was out there, and that he had been hit at the same time. I went out and found Haley, with Sergeant Donald Mclsaac and two British Tommies, in the midst of the bar- rage. We picked him up and carried him to the sunken road. Mclsaac and I then returned for a Tommy, who we had been told was wounded out there in the barrage. We could not find him, and as the Boche was then coming over the hill, we re- turned to the sunken road and got the men out of the dugouts and started them back to safety.
As the shell-fire stopped, it seemed as if hundreds of Hun aeroplanes filled the air and turned their machine-guns on us while we were crossing the field or were on the roads. They were flying so low that we could see every detail. If we had only had our arms — ! Never again !
The shortest man in the regiment is a little Sec- ond Lieutenant (one of those who has been pro- moted) who was struck in the head with a bullet
52
ROAD AND QUARRY REGIMENTS
that went clean through both sides of his steel hel- met and chipped the upper edge of his forehead on the way. If he had been one quarter of an inch taller, it would have finished him. A story has reached us through the Tommies that one of our men was found dead in the field from bayonet- wounds ; but he had three Germans in front of him, killed by the railroad pick he had wielded valiantly.
53
CHAPTER IV
FOREST AND FARM REGIMENTS
IN recruiting the Forestry Regiment only men having technical training or actual experience in forestry work were chosen. The foresters are in charge of two regular army officers, and this body includes fifteen foresters selected from the United States Forestry Service, two from the Forestry Branch of British Columbia, one lumberman from the Indian Forestry Service, and thir- teen foresters, or skilled lumbermen, taken from civil life. One thousand skilled woodsmen complete the regiment, which is divided into six companies of 164 each. No more vigorous and fearless body of fighting engineers could be found than this regiment of brawny lumberjacks, seasoned by ex- posure in many winter camps.
The foresters were among the first Amer- icans to enter war service. As early as June, 191 7, a sawmill unit, composed of 360
54
FOREST AND FARM REGIMENTS
men, was recruited in New England, com- pletely equipped with portable sawmills, and hurried abroad. The machinery and sup- plies were sufficient to make the unit self- sustaining for one year. The unit has since been at work cutting lumber in Scotland for use in France. Timber-land on Andrew Carnegie's estate at Skibo Castle, or in the vicinity, contains about 15,000,000 feet of lumber.
The lumbermen assigned to France were first assigned to two training camps, — at Washington and at Fort Leavenworth, Kan- sas,— where they were uniformed and armed like other units of the United States Army. The camp experience was intended to train these independent types of workmen in mili- tary discipline and accustom them to team- work. In this way a mobile body of work- ers has been formed to carry on the work of logging and milling in France and to solve many problems in intensive forestry.
Never, perhaps, has a more difficult prob- lem confronted America's woodsmen ; for the forests in many parts of France have been destroyed with malicious, scientific skill.
55
THE FIGHTING ENGINEERS
The American Forestry Regiment fights with weapons of characteristic power and ingenuity. Their equipment includes five complete, large, mobile, steam-driven saw- mills, which have been transported across the Atlantic and hurried to the devastated sec- tions of Northern France. Each of these sawmills can turn out 20,000 board feet of lumber every ten hours. By working the mills in two shifts, each of these mills has turned out 40,000 feet of lumber a day, while the total daily output of the combined units is 200,000 feet.
This regiment also carried to France five smaller and more portable sawmills which might be drawn by either a motor or four horses, thus saving much valuable time. The smaller mills, have an output of from 8000 to 10,000 feet of lumber, or a combined output of 50,000 feet every ten hours. A number of horses were carried along to be used in logging work, so that the Forestry Regiment suppled both the machinery and the power required.
The problem of transportation was antici- pated by carrying to France twenty-five miles
56
FOREST AND FARM REGIMENTS
of light steel rails for the construction of a railroad to carry lumber and finished prod- ucts from the forests to the front. The sci- entific ruthlessness of the Germans is thus matched against an unexpected unit of effi- ciency from overseas.
The hum of these American sawmills has sounded a new and welcome note in the for- ests of France. Once safely landed on the Continent, our men and machinery were quickly transported to the forest lands. With a skill born of long experience in American forests, the trees were felled and transformed into the finished products so anxiously awaited.
It is estimated that about 25,000,000 feet of lumber is needed monthly to supply the armies and carry on the war. For this supply the Allies must depend mainly on the forests of France. American forestry ex- perts report that the French forests consist of pine, fir, oak, beech, and other hard woods. The timber is smaller than the American lumberjacks are accustomed to, and the for- ests resemble the wood-lots of southern New England. The logs are sawed into boards 57
THE FIGHTING ENGINEERS
and dimension material ; the smaller trees are hewn into ties, poles, etc. Nothing is wasted. One of the most valuable products of the forests is charcoal. The soldiers in the trenches warm themselves by burning charcoal in small braziers, since the smoke from wood-fires would attract the attention of the enemy. Timber is selected and cut with the greatest care, so that the forests may be left in good condition for further production.
In following the fortunes of our forestry workers in France, it should be kept in mind that the men are serving in two regiments, known as the Tenth Engineers and the Twentieth Engineers. The former regi- ment, comprising about 3000 men, has been serving in France for several months at this writing. The latter regiment, whose full strength will be 7740 men, is now being re- cruited and trained for immediate service. It includes ten battalions, each commanded by a major, with the usual number of cap- tains and lieutenants. Of these officers, fifty per cent, are men who have had practical forestry experience, while twenty-five per 58
FOREST AND FARM REGIMENTS
cent, have had regular military training. The forestry regiments are representative, having been recruited from fourteen dis- tricts in widely separated sections of the country. A good idea of the versatility of the forestry regiments may be gained from the list of workmen. This includes skilled axmen, wood-sawyers, crosscut-saw-filers, tie-hewers, skidders, teamsters, wheel- wrights, blacksmiths, mill-sawyers, circular- saw-filers, expert mill-hands, carpenters, ma- chinists, and charcoal-burners. All the men are enlisted for the period of the war.
The vital need of lumber to construct rail- roads was soon relieved by an output of mil- lions of railroad ties. Several of these mills have been worked overtime at full speed, es- pecially in the winter months, to supply cord- wood for fires to warm the troops in camp. The trenches have drawn freely upon this supply.
In rebuilding cities and villages through- out Northern France our American sawed lumber has proved invaluable. Entire vil- lages have been rebuilt with such material within a few days after their evacuation by 59
THE FIGHTING ENGINEERS
the Germans. Much of this work has been standardized. Roofs have been constructed by the thousand, and these may be quickly placed on the walls of houses that have been left standing. Houses are built wholesale, taken apart, and transported to the devas- tated districts, to be set up in an incredibly short time. The advance of this American regiment into the forests of France will be remembered as one of the great achieve- ments of the war.
In building barracks and hospitals by the acre for our soldiers in France an unsur- mountable difficulty seemed to face American engineers. France was already badly in need of lumber, and the extensive barracks required for the shelter of a million or more men made a serious demand upon her re- sources. The American Forestry Regiment was turned loose on the work. The French Government assigned to their use extensive forest lands in France, and the regiment, with their battery of sawmills, advanced on the double-quick. By working these peram- bulating sawmills double-time, hundreds of thousands of feet of lumber of the desired
60
rm-:i^:
FOREST AND FARM REGIMENTS
shape and size were turned out daily, and the great barracks rose as if by magic.
The experience and energy of American foresters have in the same way worked mar- vels in restoring the mutilated forests of France. A tree that has been badly dam- aged by gun-fire, for instance, may often be nursed back to life. The modern tree-sur- geon works astounding cures. His skill in saving trees damaged by wind-storms or in prolonging the life of historic trees is well known at home. The shattered limbs are pruned with a skilful hand, or parts are re- moved and the cavities filled with the cement. Serious wounds are thus healed, while old trees are rejuvenated and their lives pro- longed indefinitely. By the application of these modern methods of intensive forestry, thousands of trees have already been re- stored in France.
In the regions seemingly devastated be- yond hope by the invaders the work of re- forestry was quickly begun. The method is familiar in many sections of the United States. Trees are grown from seeds sown in hotbeds; and these seeds sprout like grass.
63
THE FIGHTING ENGINEERS
The tiny sprouts are separated and trans- planted, and on reaching a height of a few inches, are set out in specially prepared soil throughout the regions to be reforested. A bed of small trees a few feet in extent will some day spread out to cover great areas of land. To save time, small trees are im- ported, and a small package may contain trees that will some day reclothe mountains and valleys. The Forestry Regiment has not waited for the end of the war, but pushes forward as quickly as the Germans retreat.
One of the most cruel outrages visited upon the invaded country by its plunderers has been the destruction of fruit-trees. The practice is forbidden by international law, and even in Biblical times and during the Roman conquests invaders spared such trees. Great orchards in Northern France have been ruthlessly and senselessly cut down, be- ing left, so it was supposed, to die on the ground.
Among the first to reach this devastated land have been the tree-surgeons. These men represent a branch of technical engi- neering that the Germans had overlooked. 64
FOREST AND FARM REGIMENTS
By these specialists the cross-sections of the trees are treated and joined, and the trunks are bandaged and fastened together by means of splints. A convalescent period fol- lows, when the soil is renewed and the with- ered branches are pruned away. The French soil responds quickly to the touch of a friendly hand, and many thousands of these trees have blossomed again.
No plan in the complicated problem of re- storing these devastated areas has been ne- glected. The regiments of American engi- neers have included a number of agricultural experts, who have made minute surveys of the farm-lands. On the retreat of the en- emy, these once fertile fields are often found in an appalling condition. For instance, it is impossible to imagine more hopeless fields than the region known as "no-man's-land." There the earth has literally been torn to pieces by the explosion of the most deadly shells ever devised. The crater-holes are sometimes twenty feet deep, with an even greater diameter. The heat from these countless explosions and the poisonous gases have seared the ground, killing vegetation.
65
THE FIGHTING ENGINEERS
Besides, thousands of the shells have buried themselves in the earth without exploding, and the farmers are in constant fear that a chance blow from a plough or rake will set them off.
Our engineers have collected various types of such shells and made careful tests. They have' found that a shell whose detonator has not gone off after traveling five or ten miles through the air is practically harmless. Tests, made by striking them with bars of iron, showed that the farmer's danger is ex- tremely slight. It was found, on taking such shells apart and analysing their mechanism and chemical contents, that after they have been buried in damp earth for a few months it was practcially iinpossible to explode them. Therefore the farmer may safely pick up these old shells as if they were so many stones and throw them to one side, or plough them under. The examinations of the American experts have done much to reas- sure the French farmers.
It was feared that the terrific force of re- peated explosions had destroyed the rich top- soil and would render this once fertile land
66
FOREST AND FARM REGIMENTS
barren for a generation to come. To the eye of the layman the appearance of this land is appalling. An American expert on the chemical qualities of various soils, who has studied these regions, has made a fortunate discovery. He finds that, while the non- humus-bearing, or lower, soil has been thrown up in great quantity by the explo- sions, the effect is likely to have a beneficial result. The explosions have served to loosen this lower strata, similar to the result accomplished in America when farmers dy- namite the hard-pan, so that roots may reach the lower strata with its heavier mois- ture. This expert points out that, for every pound of this subsoil that has been disturbed, a much larger quantity of the topsoil, which is rich in vegetable matter, has been widely scattered over the surface. Earth disturbed by a shell-explosion takes the form of an inverted cone, and it is the base or f rustrum of this cone that is sifted about.
After this amazing upheaval the surface soil is believed to be far richer than it was before, and thus will yield better crops for many years to come. American observers
67
THE FIGHTING ENGINEERS
have found flowers growing in such soil, — scattered clumps of petunias, nasturtiums, and snapdragons, the seeds of which had sur- vived many explosions and had doubtless been turned over many times. Often in the most hopeless-looking soil patches of corn, barley, oats, and Indian corn have sprouted, the seeds of which must have been thrown high in the air by repeated explosions. Both the flowers and the grain are stronger and more vigorous than those grown in the orig- inal soil, even when richly manured.
The fear that the effect on vegetation of poisonous gases from exploding shells will continue for many years appears to be groundless. Investigation by experts has shown that the fumes bleach the grass and shrubbery, so that it wilts and lies upon the ground, but that the roots are rarely injured and after a few days or weeks will begin to sprout again. Within a month the most rugged shell-holes are usually covered with a heavy, rank vegetation of surprising va- riety. A few months after the most violent battles the fields and crops are found to be the richest ever seen on French soil.
68
FOREST AND FARM REGIMENTS
The battle-fields are often covered with litter that can only be removed by great la- bor. The barbed wire from the entangle- ments is easily picked up, while much of it may be ploughed into the soil. The debris includes pieces of railroad iron, sheets of corrugated iron, used for roofing or lining the trenches, pieces of concrete, and many heavy objects, — all of which must be labor- iously collected and carted off, much as the farmers at home clear up a stony field.
The problem of leveling the fields and making them ready for the plough and har- row has also been carefully studied by Amer- ican engineers. To ''clean up" the rugged surface of a country, broken by innumerable shell-craters, of course involves enormous labor. Nature has, however, already com- menced to lend a hand in the work. An or- dinary shell-hole is filled up at the rate of a foot or more a year, merely by the dust blown into it and the silt deposited by the rain. The great shell-crater at Pozieres, for iia- stance, was in one year filled to a depth of many feet by the action of wind, snow, and rain.
69
THE FIGHTING ENGINEERS
Ordinary farm-tractors would prove use- less on such land. It is even found ex- tremely difficult to draw scrapers and shovels over these holes. A very happy idea has been conceived to solve this unprecedented problem. After the war, the engineers point out, there will be thousands of tanks in France without any fighting to occupy them. The ingenious caterpillar tractors, with their great driving force, are ideal tools to crawl over the most rugged country and drag after them leveling shovels, ploughs, and harrows. General Grant's famous order to let the sol- diers keep their horses to use on the fields may be repeated by turning over these great fleets of tractors to the farmers of France.
Let the Germans retreat, surrendering any sector of French fields, and the engineers and toilers of the soil are found in instant readi- ness to advance. When the enemy swept over this fertile country the peasants were always among the last to retreat. They had been accustomed for centuries to plough a certain furrow, and continued to do so un- disturbed, even when they found themselves under fire. French troops often had to use
70
FOREST AND FARM REGIMENTS
force to persuade the farmers to abandon their land, when the rich fields had to be transformed into trenches.
Once these fields have been freed from the invader, the rural population sweeps back. In an incredible short time the scars of war begin to disappear. The government engi- neers lend all possible assistance in restoring farm-machinery or replacing it. If the home and the farm-buildings have been de- stroyed, which is a common occurrence, they rebuild them, — in part at least, — or a tem- porary wooden building, manufactured wholesale, is rushed to the place.
American observers in this region are amazed at the thrift and adaptability of the French. An American family under simi- lar conditions would require continued as- sistance before it became independent. Give a French family a shelter, a pair of rabbits, a few chickens, and some food, and it is soon self-supporting. Upon so firm a founda- tion rests the future of Northern France.
Engineers have been organized for this herculean work of restoration. Every need of the farmer resident of this restored region
73
THE FIGHTING ENGINEERS
is studied with intelligent sympathy. Roads are quickly rebuilt ; bridges of every form are repaired, or new structures brought to re- place the old ones; canals are rebuilt, and streams are turned back to their ancient courses. In a single year these wastes have been made to yield valuable crops.
74
CHAPTER V
ARMS AND THE AUTOMOBILE
THROUGHOUT the United States to- day the automobile industry displays "service flags" liberally sprinkled with stars. No class of America's fighting engineers was more prompt to reach the war zone, and none has continued to recruit men more freely. Early in the war thousands of Americans volunteered to drive ambulances, motor- trucks, and automobiles of every type, and their skill and daring became familiar to the French, British, and Italian armies.
On America's entrance into the war the motor industries were quickly mobilized, and their wealth of experience in constructive work was placed at the disposal of our Gov- ernment. It is not generally realized, per- haps, that the United States, with its 4,250,- 000 motor-vehicles of all types, has about four times as many cars as all the rest of the
75
THE FIGHTING ENGINEERS
world. Considering the vital importance of the automobile in war-engineering, the weight of these resources is certain to prove a vital factor in winning the war. Since 1 914 the United States has supplied the Al- lies with more than 50,000 motor-trucks, to- gether with an army of men to run them.
Since many of the officials of the leading motor manufacturing companies have volun- teered and received commissions, the best en- gineering talent of the country is to-day in the service of our Government. Twenty- five representatives of our leading automo- bile manufacturers are in France, adminis- tering the motor-service. A single organi- zation— the Motor-Truck Club of America — has recruited 2000 chauffeurs, of whom 1400 have been mustered in. At the request of the Government, training schools have been established for transport-officers and men. All kinds of workers in the automo- bile industry are being specially trained, in order that this great power may be directed efficiently.
No other service of our fighting engineers has been recruited in such force. For ev-
76
ARMS AND THE AUTOMOBILE
ery twenty-one men America will have under arms, she will furnish two motor-vehicles. An army of 1,000,000 soldiers will be sup- plied with 95,000 automobiles of a bewilder- ing variety of types. The greatest mobiliza- tion of motor-vehicles heretofore was at Verdun, where the cars, if placed fifteen feet apart, would have extended more than six hundred miles. Even France, however, could only find one motor for every fifty men in her armies. The English army has man- aged to keep its front supplied with food and other necessities by employing one car for every sixty-six men.
As late as the spring of 191 6, when Gen- eral Pershing was ordered to Mexico, the army was absurdly unprepared as to its mo- tor equipment. Great difficulty was expe- rienced in finding a score or more of motor- trucks adapted to the carrying of supplies to the army. In a period of less than two years the United States Army has become the best motorized army in the world. Until the Mexican trouble the motor was not popular in the army. It is a great tribute to Ameri- can ingenuity and energy that in this brief
77
THE FIGHTING ENGINEERS
period so many new types of cars, suited to every service should have been designed and manufactured at a rate unprecedented in history. During the present year the United States will turn out 2,000,000 passenger-cars and 200,000 motor-trucks.
Among the invaluable services automo- biles of every type have rendered throughout the war, three great achievements, at least, will go down in history. The rapid advance of the German forces through Belgium would have been impossible without the sup- port of motors. The transportation of men, ammunition, and food was accelerated be- yond all precedent, to the bewilderment of the Allies. Such an advance gave their op- ponents little time to mobilize, and Belgium was overrun before the French army could be brought up or England's expeditionary force could cross the Channel.
But the French were quick to turn this same weapon against the invaders. Years of preparation had given the Germans great fleets of motor-trucks, which now stood ready to advance at a moment's notice. Within a few hours France had learned its
78
ARMS AND THE AUTOMOBILE
lesson, and when General von Kluck's army threatened Paris it was the automobile that saved the capital.
The French army did not possess motors in sufficient numbers, and Paris was drawn upon with feverish haste. The smooth, level roads running out of Paris proved invalu- able. Every form of car was pressed into service. Unbroken streams of automobile traffic were soon set in motion. Motor- trucks, taxicabs, auto-busses, and every form of private car were loaded with soldiers. The men filled the bodies, lay upon the roofs, and clung to the running-boards as the cars dashed forward. So great a force had never before been transported over open country at such a pace. But Paris was saved I
Later, when the enemy concentrated his forces at Verdun, the motor proved the force behind the front that held the line firm. So great a mobilization of motors had never be- fore occurred in history. It is estimated that the ammunition carried by a standard auto-truck will supply one of the French guns for ten minutes. This army of motors moved in an endless stream over the famous
79
THE FIGHTING ENGINEERS
Vergennes loop. On many of the roadways near the front the congestion of automobiles exceeded that on great American thorough- fares,— even that on Fifth Avenue during the rush hours. As the traffic converged at the front, the stream of vehicles knew no in- terruption through the twenty-four hours.
The rapid evolution of the war automobile was unforeseen. Twenty years had been required to develop the early types of "horse- less carriage" to the present models, but the necessities of war demanded quicker action. It is estimated that to-day there are over 100,000 automobiles of various types on the Allies' side of the trenches.
A highly-specialized form of automobile is demanded for war. At first the ordinary type of commercial truck was employed; but under new and untried conditions it proved inefficient. The war truck must be light, yet capable of hauling a trailer and of operating over rough roads. The five-ton truck of commerce answered no better than the orig- inally designed two-ton truck, and a compro- mise was finally struck by building a three- and-a-half-ton truck.
80
ARMS AND THE AUTOMOBILE
Even to the experienced motorist the re- sults of countless experiments in developing a standard type will come as a surprise. It has been found that four cylinders serve bet- ter than six. To get the best staying power out of a loaded car on an eight per cent, gra- dient, new gears and systems of piston-dis- placement had to be worked out. The chain- drive is replaced by the worm-drive. Gaso- line is the only fuel that will stand up under the strain. On poor roadways a driver can- not hope to get more than 1500 miles out of his tires, and often it is only 200 miles. A hundred details of construction have been changed, reversing the familiar experience of experts in less troublous times.
Early in the war, as the armies began ''to dig themselves in," French engineers looked about for labor-saving devices for trench- ^iiggiiig- The problem presented was unpre- cedented. Thousands of miles of trenches had to be dug; and time was priceless. If the work were done by hand, as in the early stages of the war, a great force of soldiers must be thus employed who were badly needed for fighting. It was at length de-
83
THE FIGHTING ENGINEERS
cided to intrust the problem to American in- genuity.
Thereupon several manufacturers of ma- chinery in the United States were invited to study the problem and devise a new type of ditch-digger, suitable for military work. The trench-digger constructed in America and rushed to the front proved to be one of the most dependable engines of the Great War, and it has released many thousands of soldiers for more active service.
The operation of this trench-digger is as follows : Upon the heavy motor-truck chas- sis, so familiar in the United States, is mounted an ingenious bucket-excavator of the continuous-belt type. The buckets, car- ried steadily forward by the belt, scoop up the earth at a surprising rate, and carry it up to chutes which dump it to one side of the machine. The machinery is so powerful that it will attack any soil however hard and rocky. The belt, with its train of buckets, may be quickly adjusted to any angle. By merely shifting a lever the power is supplied by the motor of the automobile. An engine of 100 horse-power has been found sufficient
84
ARMS AND THE AUTOMOBILE
to drive the machine at a rapid pace, and to operate the digging apparatus in the toughest soils. Each digger, manned by a crew of only five men and a chauffeur, readily does the work of one hundred soldiers armed with the primitive pick and shovel. Each bat- tery of ten diggers, therefore, releases a reg- iment of men.
A fleet of trench-diggers is probably the most mobile unit among all the constructive machinery employed in the Great War. These machines are held in instant readiness for any movement, like so many fire engines. The crews sleep beside their machines, ready to spring to their places and rush their en- gines to any part of the field. Let the enemy retreat or advance, so that a new line of trenches is required, and the trench-diggers are rushed to the point as quickly as our fire- men respond with their engines and ladders. The digging machinery is set in rapid mo- tion. While the troops a few feet away may be checking the enemy's advance, a trench is scooped out of the earth, and thus by the aid of this shelter the day is saved.
It is estimated that if all the trenches dug 85
THE FIGHTING ENGINEERS
in the present war were straightened out and placed end to end, they would more than circle the earth. It would have been impos- sible without the trench-diggers to dig 25,- 000 miles of trenches of the modern type. Much of the work, of course, is carried on well behind the firing-line. As the trench is cut out, workmen strengthen the sides with boards, limbs of trees, or metal plates. Grooved steel plates, about ten inches in width and six feet in height, are often em- ployed. These may be slipped into place and securely locked without the use of screws or hammers.
Another characteristic American inven- tion is a searchlight mounted on a collapsible tower and carried by a fast motor-truck. It resembles the familiar water-tower of our fire departments. The searchlight is of the powerful type used in the navy. When un- der fire, or when traversing rough country, the tower is folded back, so that the car is no more exposed than is an ordinary automo- bile. The electricity for the lamp is gener- ated by the automobile-engine.
[The searchlight may be rushed to any 86
ARMS AND THE AUTOMOBILE
point to which an automobile can penetrate, and the light may be raised to its maximum height as quickly as our tower-hose is brought into action. Its powerful rays will illuminate an object many miles distant, thus revealing the activities of the enemy when he least expects it. Again, from its elevated position it will light up a large tract of land, turning night into day. The first of these American searchlights accompanied the First Regiment of United States Engineers. Among countless types of specialized auto- mobiles for war use now built in America are a number of trucks equipped to repair shoes. These are manned by crews of ex- pert shoemakers and carry the latest shoe- making machinery. The waste of shoes at the front is enormous. After a battle dis- carded shoes are picked up by the thousands, and the perambulating cobblers set to work. No shoe is so badly worn that some part of it cannot be utilized. When the leather is stiff it is soaked in chemical baths until pli- able, after which it is scraped and patched. Even when a shoe is hopelessly worn out, some part of it may be cirt away and used
87
THE FIGHTING ENGINEERS
again. Thus nothing is wasted. A single shoe-repairing unit will sometimes turn out two thousand shoes in a day.
Were it left to a popular vote, the favorite unit of equipment carried by our engineering regiments to France would doubtless prove to be the motor-kitchen. The perambulating kitchen, — which is really a marvel of com- pleteness,— is mounted on a powerful motor- truck, and may be rushed along ordinary roads at a forty-mile pace if occasion should demand.
The kitchen has three main compartments : a refrigerator at the front, a storage place for perishable foods amidships, and a large three-open range at the rear. On this range four large kettles or pots may be heated at a time. Overhead, an ingenious system of derricks and block-and-tackle devices enables the cook to move his cooking-utensils about with ease.
In no branch of the service is the motor- vehicle so indispensable as in the Ordnance Corps. Trucks to carry ammunition and tractors to haul the big guns have been con- structed for this corps on a lavish scale. It
88
ARMS AND THE AUTOMOBILE
is estimated that the Ordance Department will have in all about 60,000 motor-vehicles, and of these fully 10,0000 will be tractors. A three-ton truck, which seems so efficient in our city streets, will carry enough ammu- nition to supply one of our ten-inch howitzers for about ten minutes. It is obvious that an unbroken line of motor-vehicles must span the spaces between the supply-bases and the great batteries, if the artillery fire is to be continuous. The Quartermasters' Depart- ment will have about half as many trucks as the Ordnance Department.
No engine of warfare has undergone so complete a transformation in so short a pe- riod of time as the "land-ships," or tanks. The armored automobile, from which tanks have been evolved, had appeared in several forms before the war, but no great conquest was hoped for it. In the construction of the primitive machine a conventional chassis was employed, and the more vulnerable parts were protected with light armor-plate. A light field-gun was sometimes mounted on it. In no sense, however, was it a fort, being de- signed to carry despatches or to convoy
89
THE FIGHTING ENGINEERS
troop-trains in exposed territory. During the early stages of the war in Belgium such cars were used with good effect in small frays, in attacking enemy outposts, and in surprise attacks preparatory to a general ad- vance.
As the great armies settled down to trench-warfare all roads in the vicinity of no-man's-land disappeared, and even the lightest cars found the open country impos- sible. The usefulness of the armored auto- mobile seemed at an end. The tanks, which are perhaps the most sensational achieve- ment of the fighting engineers, came as a complete surprise. In their present form these tanks are virtually perambulating forts whose defenses are proof against any ordi- nary attack that field-troops can direct against them.
To the enemy, the most baffling feature of the tank is its ability to move at will over land that would be impassable for ordinary vehicles. The gaping shell-craters and fur- rows of these areas, though cut wide and deep, are, nevertheless, readily surmounted by the new engine of war. The tank is
90
ARMS AND THE AUTOMOBILE
mounted on endless corduroy belts, and is steered by large flange-wheels at the rear. In passing over the roughest land the tank maintains a speed of looo yards an hour, or something more than a half-mile. When the first of these tanks appeared in America, taking part in a military parade on Fifth Avenue, it moved over the paved street at the speed of an ordinary pedestrian and with surprising smoothness.
The British land-ships are of two forms, known as the "male" and "female" tanks. The male, which is the more formidable, has sponsors built On either side, in which six-pound guns are mounted behind movable shields. The sponsors are sometimes built with five sides, so that the guns may be swung in a wide arc, covering the ground at the sides, and can be fired parallel to the axis of the tanks.
Each of these cars also carries several ma- chine-guns, or at least four "Lewis" guns, to serve as a supplementary battery. The fe- male tanks are less deadly than the male, and each carries six "Lewis" guns. The tanks weigh thirty tons. They are driven by 105-
93
THE FIGHTING ENGINEERS
horse-power motors of the silent type. The crew of each tank consists of an officer and seven men.
These perambulating forts are impreg- nable when attacked by either rifle or ma- chine-gun. The armor employed at present consists of plates one fourth of an inch in thickness, made of steel of a special compo- sition. The openings for the guns are so contrived that the crews are comparatively safe from attack, even though the tank be surrounded by the enemy. These tanks are painted fantastically in brown, yellow, and green, to make them harmonize with the landscape. While advancing at night or in a fog they are very difficult targets to hit.
The sensations of the crew in an attacking tank furnish experience unique in warfare. The interior of the traveling fort barely ac- commodates the crew of seven men. The steering-wheel is placed forward, so that the driver may look ahead through narrow slits in the armor. The two field-guns are mounted amidships. The tanks have no springs of any kind, which makes rough go- ing for the crew. Since the forward end
94
ARMS AND THE AUTOMOBILE
rakes up at an angle of thirty degrees, to en- able it to climb trenches, the tank is often pointed at an even steeper angle, when the crew must hold on by main strength. The jolting when passing over rough ground is extremely painful. It is said that if the tanks moved faster than looo yards an hour over such surfaces, the movement would be- come dangerous for the crew. Increase this motion by the violent vibration of the steel walls as they are peppered with the fire from rifles and from machine-guns, often dis- charged point-blank at the tank, and a ride in the enemy's territory becomes a strenuous experience.
In the famous advance of the tanks at Cambrai one of these traveling forts became separated from the fleet, and at a critical mo- ment its engine suddenly stalled. The Ger- mans, who had been keeping at a respectful distance, hailed this accident with shouts of joy, and rushed forward. As the driver struggled frantically with his engine, the enemy swarmed about the tank, climbed upon it and sought the observation openings, in order to shoot the crew like rats in a trap. -95
THE FIGHTING ENGINEERS
At such short range the guns of the moving fort were useless, and to open the doors and make a sortie against such overwhelming forces would have been hopeless. At this critical moment the engines — as is the way of engines — suddenly ''picked up." The tank moved slowly forward, and then, gath- ering momentum, shook off the enemy cling- ing about it and soon crawled within the pro- tecting range of its brother-tanks.
The French tanks differ materially from the English models. In the former the belts are better protected from shell-attack and are less liable to break. They are shorter than the British, however, and such tanks are likely to get stuck in crater-holes from which a British tank might readily crawl out. The French tanks carry on their roofs a camou- flage canvas, which can be readily unrolled and let down to cover the tank when at rest. Many of these machines carry the famous French 75's, mounted inside the car, with their muzzles pointing directly ahead.
With America's entrance into the war has come a new development and a more general application of the tank. ^The British used
96
ARMS AND THE AUTOMOBILE
the American tractor as the basis for their tanks, increasing the motive power and pay- ing special attention to heavy armor and large guns. The result has been the con- struction of formidable moving forts, with a corresponding loss of lightness and mobil- ity, which thus renders them rather clumsy in supporting infantry action. The French made fewer changes in the original Ameri- can model and employed lighter armor and guns. At the same time their tanks are less cumbersome and less powerful than the Brit- ish type.
Profiting by the experience of the English and the French, the latest form of American tank combines the two systems. A great fleet of tanks of several types has been built for General Pershing which includes both heavy and light machines, the fleet being thus adapted to a variety of purposes. The heavier American tanks will be used to sup- port our artillery in the field, while the lighter models may be used for transporting artillery and motor-lorries over rough roads where ordinary automobiles could not pass. A bat- tery of field-guns may thus be drawn into ac-
97
THE FIGHTING ENGINEERS
tion under a fire that would prove deadly to exposed troops or ordinary automobile-trac- tors. In other words, American tanks will fight the enemy and bring heavy guns into action at the same time.
American forces have been provided with tanks in the same liberal spirit that marks the supply of other equipment. An appropria- tion of over $50,000,000 has been set aside to construct these fleets of tanks. Their motors will range from 12 to 250 horse- power. Many of our tanks have already been completed and shipped safely to France. With such a fleet at his disposal, General Pershing, thanks to American engineering ingenuity, will have enough tanks to keep up with infantry advances and maintain a sus- tained offensive action unique in the history of warfare.
98
CHAPTER VI
THE FAMOUS IITII ENGINEERS
GENERAL GRANT is credited with saying that his troops, recruited from many trades and professions, formed the most efficient army ever assembled for solv- ing engineering problems. In recruiting the nth Engineers this ideal of general efficiency has been completely realized. The regiment is beHeved to be unique in the history of war- fare. Among its 1300 engineers and skilled workmen is enlisted much of the best talent in America. Many of the engineers have cheerfully given up large incomes in order to devote their skill and, if need be, their lives to the service.
In no department of engineering is Amer- ica better prepared to lend assistance than in work connected with the water-supply. Throughout the United States every con- ceivable problem of supply has been encoun-
99
THE FIGHTING ENGINEERS
tered, and this varied experience has served to train a great body of highly efficient work- men. The Catskill Aqueduct, for example, outclasses any similar work abroad, while the famous Roman aqueducts seem primitive by comparison. A number of engineers prominent in the Catskill project are to-day in France, as are hundreds of others whose names are associated with the greatest engi- neering projects of our country. In a recent letter from the front a former Catskill en- gineer writes that he finds the work abroad the most difficult in all his experience.
Several of the engineers of this regiment have been assigned the ambitious task of sup- plying water for great bodies of troops, as well as for cities and towns throughout France. Projects which would require years to plan and build at home must now be rushed through, for a day's delay may cause disaster. Much of the work must be done under fire. A lucky shot from a German battery may destroy at a stroke the labor of weeks, but the engineers must be ready day and night for any such emergency.
Watersheds have been selected and sur-
lOO
THE FAMOUS iith ENGINEERS
veyed. Dams are built and water-mains laid for miles up hill and down dale. The mains are carried over rapidly-constructed trestles, or, again, are concealed from the German fire by ingenious camouflage. It is often dif- ficult to find suitable material, and ingenious makeshifts have to be resorted to. The regi- ment includes several bacteriologists whose judgment is followed in anaylzing water or the soil through which it drains. One of the first duties of these bacteriologists on reach- ing reoccupied territory is to make careful analysis of the wells and water-courses, since the Germans frequently poison them when evacuating the country.
To complete the work of devastation, the enemy, on retreating, often floods great tracts of land. The skill of American en- gineers had not been counted upon in these plans. It is just such problems that our en- gineers, fresh from great Western irrigat- ing projects, are prepared to face. No time is lost in theorizing. Surveys are quickly completed, and large forces of men attack the work. By some ingenious arrangement of dams and sluices, or the hasty construc-
lOI
THE FIGHTING ENGINEERS
tion of new water-channels, large areas of country have been drained in a few hours. Invaluable work is being done in purifying the water-supplies of camps and cities by modern methods employed in the United States.
A well-known American engineer, now in France, recently wrote to a friend at home, asking him to send some illustrated cata- logues of the American machinery commonly used in water-supply. He explained that he did not wish to buy such machinery, and could not get it over if he did, but he wanted to have the satisfaction of showing the cata- logues to the French and English engineers, who could not believe that such machinery as he described actually existed.
The war has necessitated mining opera- tions on an enormous scale. Expert geolo- gists are enlisted to examine the soil and de- cide what material will be encountered at different levels in the regions to be tunneled. One tunnel 1663 feet in length has been ex- cavated, for example, from which 2200 cu- bic yards of earth and rock were removed. The miners use pneumatic rock-drills and all 102
THE FAMOUS iith ENGINEERS
the latest mining machinery. The working- squads consist of twenty-five or thirty men, laboring in shifts of six hours.
Excavations usually take the form of long tunnels, dug at a slight incline to the hori- zontal. Such tunnels are often run ahead of the front trench for a length of lOO to 125 feet under no-man's-land, which carries them directly beneath trenches occupied by the enemy. On reaching the desired point, the tunnel is widened to a chamber where ex- plosives may be placed. In such work the dimensions are kept as small as possible, leaving only room enough for the dirt and stone to be removed. The longer tunnels are usually kept three feet wide and from four to six feet high. When not over 100 feet in length they are only three feet high, while the width is often not more than thirty inches. In order to save time, which is priceless under such conditions, the men work in tunnels that compel them to stop over and crawl about the excavations like moles.
The progress of the work depends, of course, upon the nature of the material to be removed. If conditions are favorable, a 103
THE FIGHTING ENGINEERS
tunnel may be pushed forward at a rate of from fifteen to twenty feet every twenty- four hours. When the earth and stone of- fers great resistance, progress may be re- duced to three feet a day. The earth may prove to be so soft that the roof of the tunnel must be continually braced with timbers. As the tunnels advance, narrow tracks are laid and small cars, pushed by hand, are used to carry the earth to the opening of the shaft. One of the greatest dangers that faces these fighting engineers is that their work will be discovered by the enemy and a counter-mine be employed against it. It sometimes hap- pens that engineers will locate the position of an enemy tunnel, force a hollow pipe un- der it, and explode a mine directly beneath the workmen. An alert watch must con- stantly be maintained by the miners far un- derground to detect the approach of an en- emy tunnel. It can readily be seen that modern American machinery and methods, such as the electric and pneumatic drills em- ployed by oair American engineers, are prov- ing invaluable.
The idea in such work is, of course, to un- 104
With the foreslry regiment
m
THE FAMOUS iith ENGINEERS
dermine the enemy's position, while excavat- ing soil that offers the minimum amount of resistance. When the tunnel has reached its maximum length, the explosives are set in position and electrically connected with the base. The tamping is done with concrete, sand-bags and heavy wooden beams. The famous ridge at Messines was undermined by ninety excavations, in which five hundred tons of high explosives were simultaneously exploded.
In recruiting a large force of mining engineers and experienced mine-workers America draws upon a large and skilful body of men. Only those men were selected who had had much actual experience as engineers. They are men who know rock and soil and who can judge its strength at a glance. In this force men are to be found capable of solving every possible mining problem that may be encountered.
It is a high tribute to America's reputation in this field that the French Government has entrusted some of its important mining oper- ations to this regiment. Both coal and iron mines are being worked in France to-day by 107
THE FIGHTING ENGINEERS
complete units of American miners. One of these units can take over the entire work of operating a mine — the location of ores, the construction of tunnels, the building of sup- porting timbers, and the laying down of rail- roads for the purpose of getting out the ore.
The miners cheerfully face a lively danger in their tunnel-work in the front-line trenches. Here they must select the most vulnerable point in the German lines and run long tunnels forward under the enemy posi- tion. By exploding mines directly beneath the trenches, the way is prepared for an ad- vance. In order to carry out such enter- prises, the miners must know earth and rock, and must stake their lives upon their judg- ment. A mistake in calculating the strength of materials may cause them to be buried as they work, or may attract the attention of the enemy before the tunnel is completed.
The workers in subways or tunnels are ob- jects of sympathy, but their position is safe by comparison with these men. One of the most perilous tasks the mining engineer workers are called upon to perform is to extend hollow pipes from the front-line io8
THE FAMOUS iith ENGINEERS
trenches under the enemy's position. High explosives are set off at the end of these pipes by an electric-spark. The position of the soldiers in the front-line trenches is at best perilous, but that of the workmen, whose re- treat is practically cut off, calls for rare cour- age.
In preparing for General Byng's famous drive, it was found absolutely essential that a considerable amount of engineering work be completed before the advance was or- dered. This work was entrusted to Ameri- can engineers, assisted by American work- men. A British officer high in command urged that the work be rushed as fast as pos- sible, and asked for an estimate of the time required. It was decided that even by work- ing on an American time-schedule more than eleven days would be required. The censor has not permitted any description of the na- ture of this work to come through.
The British staff decided that they could not wait eleven days to begin the drive, and urged greater speed. A great force of coolie labor was offered to hasten the work. This offer was refused, the American engineer 109
THE FIGHTING ENGINEERS
much preferring his own workmen. The construction work was completed, neverthe- less, in less than five days, and the famous advance started on schedule time. The en- gineer in charge of this work has written home that he found time for only eight and a half hours sleep during more than five days. The end of the job found him so exhausted that he lay down beside a battery of twelve- inch guns, and even their bombardment failed to disturb him. The work of the Americans has received most enthusiastic praise from British officers.
When the proportion of deaths and cas- ualties is definitely counted after the war, it will doubtless be found that the fighting en- gineers have suffered severely. Apart from the obvious danger of working under fire, these men are exposed to every kind of ac- cident common among workers with machin- ery. In the building and operating of rail- roads on rush-schedules, under new condi- ♦ tions and while using new and unfamiliar materials, the risk is naturally great. Re- ports of such accidents are already coming in, and the demand for false limbs, glass no
THE FAMOUS iith ENGINEERS
eyes, and other surgical material tells its own story.
The first man of the American engineers to be invalided home is, at this writing, in a hospital in Baltimore, suffering from a broken hip. A railroad accident is likely to be more serious than a bullet-wound, and the fighting engineers face both dangers.
The spirit of the American engineers at Cambrai, which has been so highly praised abroad, was no surprise to their friends at home. The British Commander in Chief, Sir Douglas Haig, has especially praised and recommended for a decoration Lieutenant Paul McLoud, of the American Engineering Corps, for his bravery in the Battle of Cam- brai.
The Americans were busy on the morning of November 3, 1917, building a railroad- yard near the British front, when they were surprised by a sudden German advance. Without a moment's warning, the Germans concentrated a heavy artillery-fire on the yard. Lieutenant McLoud collected his men and calmly marched them through the Ger- man barrage to a point of safety. They had III
THE FIGHTING ENGINEERS
retreated about two miles, when they chanced upon a number of British soldiers. McLoud at once took command and, rallying the troops, returned to the firing-line. On the way back the Americans met a British staff officer, and with his aid they succeeded in getting additional arms and ammunition with which to equip the engineers of the party.
Once armed, the improvised troops rushed forward and were soon in the thick of the fight, giving an excellent account of them- selves. Lieutenant McLoud was formerly chief engineer of the New York State High- way Department, and was one of the first to enlist in an engineering regiment. It is from such material that America has recruited her regiments of fighting engineers.
The bravery of the fighting engineers at Cambrai called forth the following letter from Colonel Henry W. Hidge, U. S. A., to Mr. Mac Isaac the father of one of the men. The colonel writes :
I want to write you a line of congratulation on the conduct of your son in the recent conflict with the Boches.
Every one here says that, but for his heroism and
112
THE FAMOUS iith ENGINEERS
those who were with him from the Engineers,
we might have had a serious fall-back, but that he and Lieutenant McLoud and a few others rallied their men and our soldiers and held the Boches. I hear that the Allied commander will probably give especial recognition to their gallantry, and 1 am sure that you will be glad that your boy is one of the first to show that we Americans are going to do our part in this great struggle.
At the present writing, at least fifteen members of the nth Engineers are known to be prisoners in Germany. The capture was made in the famous advance at Cambrai, and indicates that the Americans must have been very near the first-line troops. In this campaign an advance was originally planned on a thirty-mile front, with the assistance of the famous tanks. Later the forces were concentrated, but, as all the world knows, the British troops pushed forward for five miles.
The wedge thus driven into the enemy's territory was open to attack on three sides, which rendered the position extremely pre- carious. The American engineers, never- theless, pushed forward into this territory, in
113
THE FIGHTING ENGINEERS
order to consolidate the position. A simul- taneous attack quickly developed on three sides, and the position proved untenable. Doubtless our engineers could have saved themselves, but they remained at their posts until overtaken and made prisoners. ,
The relatives of members of the nth En- gineers have formed an association in New York, an example that may well be followed elsewhere. Headquarters have been estab- lished, a paper is published in the interests of the organization, and monthly meetings are held. The work of communicating with the men at the front and of caring for their families at home, if need arises, is carefully organized. An attractive feature of these meetings consists in reading letters from the men at the front, and plans are discussed for lending every possible assistance to the men in the camps, the wounded, and to prisoners. The honor list of the month, including the dead and wounded, is read, patriotic songs are sung, and prayers are offered. A collec- tion for the engineers is taken up by passing around a German helmet captured in the war.
114
CHAPTER VII
THE MAN BEHIND THE GUNS
MANY revolutionary ideas in the sci- ience of gunmaking have had their origin in the United States. By some bold stroke the American engineer has repeatedly set aside the usage of years and opened up an entirely new field of scientific conquest. Later the idea has been seized upon by Eu- ropeans, carried to perfection, and, in its ultimate development, turned against us. It is a proof of the peaceful ideals of one na- tion that, after originating ideas that may revolutionize warfare, we have allowed oth- ers to apply them.
So rapid has been the advance in military science that the weapons of a generation ago are to-day only fit for decorations, — of doubtful artistic value, — in our public parks. The best guns of the Civil War period, made of cast-bronze or wrought-iron and strength- 115
THE FIGHTING ENGINEERS
ened with metal bands, are as extinct as the stage-coach. Even the field-guns of the Spanish War are hopelessly outclassed. The field-artillery of the United States Army, previous to the Great War, comprised seven or eight types of guns, varying in bore from three to seven inches, which armament compared favorably, however, with the best European ordnance.
The marvelously complex gun of modern warfare dates from the Crimean War. With the appearance of the breech-loading weapon, the ordnance which had determined the issue of battles for centuries began to disappear. Even the guns heard at Trafal- gar and Waterloo were soon silenced for- ever.
The first great cast-iron guns to be used in actual battle were of American make, al- though they were heard in Europe during the engagement between the Kearsarge and the Alabama, in the English Channel, in 1864. At that period American guns were acknowl- edged to be the best, since American iron had a tensile strength of 40,000 pounds per 116
THE MAN BEHIND THE GUNS
square inch, as against 20,000 pounds for English iron.
But the heaviest guns of cast metal could not long withstand the explosions of modern charges, which appeared after the Crimean War, and the barrels were soon made of con- centric tubes welded together. American guns were strengthened by hoops of iron shrunk around the breech. Many experi- ments were tried, and the modern gun slowly took shape. The steel tubes that form the lining were first forced into the guns, but later the outer case of the gun was shrunken about them.
By the year 1874 guns were made in Eng- land with an inner tube of steel encased in no less than five coils of wrought iron. The largest of these guns fired projectiles weigh- ing 1258 pounds, the power charge weigh- ing 170 pounds. Wrought-iron gradually disappeared, and the guns were made entirely of steel. The first all-steel gun appeared in France at so recent a date as 1881.
The best engineering talent of the world has been engaged upon this problem of gun- 117
THE FIGHTING ENGINEERS
making. After countless experiments, all countries seem agreed upon the best method for turning out gun-barrels, much as details or workmanship may vary. The steel is first cast in ingot molds in the form of solid, truncated cones. The ingots are roughed out with several reheatings of the steel, and are then turned and bored roughly. The core is cut away and taken out in a single piece. An oil bath is employed in tempering the steel, when the rings are shrunken on, and the gun is ready to be filed. It has been found that a wire-wound gun offers greater resistance than one strengthened by any sys- tem of hoops. The tension the gun must withstand is, of course, calculated in ad- vance ; nothing is left to chance.
The secret of the enormously increased effectiveness of modern ordnance lies, of course, in its power of resistance. There are two ways of increasing the firing-power of a gun : by lengthening its tube and by in- creasing the charge. The early guns had a lensfth of twelve diameters. Some of the latest guns are fifty times that of their bore. The muzzle velocity of the high-powered ii8
THE MAN BEHIND THE GUNS
guns of the past was 7000 foot tons, as com- pared with about 53,000 foot tons in the case of the largest modern ordnance. An in- crease of 800 per cent, in driving force is thus obtained.
The force of explosions has been increased by using nitro-explosives in place of gun- powder. Again, by using smokeless powder a much larger volume of gas is obtained than by the use of black powder, and hence its increased effectiveness. The wrought-iron guns had an elastic limit of twelve tons per square inch, while the limit of steel is twenty- one tons.
Before the opening of the Great War the artillery available for use in the field included several types of direct-fire gun, ranging in caliber from three to four inches, with high- angle-fire guns or howitzers of from 4.7 to 7 inches. The largest of these guns in the United States fired seven-inch projectiles. Some European countries were known to have larger guns, — even eight-inch guns.
Meanwhile Germany had been secretly building and testing guns of unprecedented power, which for a time were to spread con- 119
THE FIGHTING ENGINEERS
sternation among her enemies. The Krupp gun-works had turned out giant howitzers of 12 and even 16.5 inches. Tests were made on carefully-guarded proving-grounds, and the "Busy Berthas," as they came to be called, were held in readiness.
In designing this unheard-of ordnance the German engineers had definite targets in mind. The guns were intended to reduce the concrete foundations of Liege, Namur, and Maubeuge, which were supposed to be im- pregnable. The idea, by the way, did not originate with the Germans ; for similar guns had already been used by the Japanese against the Russians in Manchuria. Bor- rowing the idea, the Germans stole a march on their adversaries. Experts are not yet certain whether these great guns should be classed as howitzers or mortars. The true howitzer has a barrel somewhat shorter in proportion to its bore. The mortars of late years have been growing larger, but then, again, the new guns are too large for this classification.
The world was not prepared for the explo- sions of the ''Busy Berthas." The shells, 120
THE MAN BEHIND THE GUNS
weighing looo pounds or more and aimed with amazing accuracy, crumpled up the sci- entific foundations of modern forts eight miles away. For some anxious days it seemed as though they could batter their way to Paris. Later they were used with appal- ling effectiveness to destroy trenches at Ver- dun. A single shot has buried fifty men, and their explosion is said to kill men within a ra- dius of 150 yards. The Austrian "Skoda," a howitzer of 17 inches, throws shells weigh- ing 2800 pounds. In the bombardment of Duirkirk fifteen-inch shells were hurled twenty-two miles.
The efficiency of such guns is due to the fact that they are readily portable and may be carried with surprising speed from place to place. Heretofore, guns of enormous power have been stationary and have only been available for coast-defense purposes. The new guns are cast in three parts, each of which may be loaded on a motor-truck of special construction. The gun is trundled on one truck, the carriage on another, and the foundation on a thirci. A crew of sev- era.l hundred men is employed to transport 121
THE FIGHTING ENGINEERS
them. If the country permits, trucks are employed, while specially constructed rail- road-cars are sometimes used. It is said that the gun-crews are always ready, on a moment's notice, to destroy the guns by blow- ing them up, if they are threatened with cap- ture.
Against the unprecedented attack of the "Busy Berthas" the Allies for a time could bring no adequate defense. But the reign of the "Busy Berthas" was short-lived. Al- though they were met only by guns of in- ferior size and range, the French set up an impregnable barrier, and the giant guns never arrived within range of Paris. By the time the Battle of Picardy was fought, the British were able to utilize great howitzers that threw shells weighing 1700 pounds a distance of seven miles, at a rate of one shot a minute. Like the German and Austrian ordnance, these guns were brought up on motor-trucks. In the Battle of the Somme the pendulum had swung back, and the Al- lies, completely outclassing the enemy, di- rected against them the heaviest artillery-fire known in warfare.
122
<c- '.
THE MAN BEHIND THE GUNS
The gun-makers of every country at war realize that probably the greatest problem in building modern guns is that of overcom- ing the recoil. Until recently the kick of a gun was considered a necessary evil, and no effort was made to control it. A cannon, on being discharged, would run back several feet, and the aim would be completely lost. A crew was then forced to labor to bring it again into position, and the difficult work of sighting it had to begin all over again. The time lost between shots was, of course, price- less ; but since both sides worked at the same disadvantage, it was accepted as a necessary evil.
With the present system of non-recoil em- ployed, a battery of field- or even siege-guns can be made to fire from twenty to twenty- five shots per minute. The problem has been solved in different ways in the several em- battled countries, but the construction is essentially the same. The carriage of the gun remains fixed, and the gun recoils on this carriage and returns to its original position. The force of the recoil is enormous, but this is taken up by a highly ingenious system of 125
THE FIGHTING ENGINEERS
hydraulic cylinders, counter-weights, and counter-recoil springs.
It is difficult for the lay mind to realize the power of such guns. In the case of a twelve-inch gun the counter-weight consists of 140,000 pounds of lead. The recoil-cyl- inders are filled with oil, which has been found best for taking up the stupendous shock of the discharges. The guns are re- turned to their carriages by releasing the great counter-weights, thus forcing the weight of the gun forward to its firing posi- tion.
In no other branch of engineering, it is safe to say, may be found mechanism at once so powerful in its execution and so delicate in design. One type of our seacoast guns measures fourteen inches in caliber. This measurement means little to the average mind, although our respect for the gun will rise when we learn that it fires a projectile weighing 1660 pounds, which, in turn, car- ries a bursting charge of eighty-five pounds of high explosive.
The largest gun in our fortifications is of sixteen-inch caliber ; it is mounted on a dis- 126
THE MAN BEHIND THE GUNS
appearing gun-carriage. The almost irre- sistible force of this gun is cleverly utilized to operate much delicate, but powerful, ma- chinery to bring it back into position in the shortest possible time.
This gun-projectile weights 2400 pounds, — a weight equal to that of a large wagon or automobile filled with passengers. Its speed on leaving the gun, or its muzzle-velocity, is 2700 feet, — rather more than half a mile per second. The energy exerted by such a dis- charge is equal to 121,430 foot tons. This power will raise a projectile weighing more than a ton to a height of eight and a half miles, an altitude equal to that of several of the highest mountains in the world.
The extreme range of such a gun is twenty-seven and one third miles. To vis- ualize this distance, describe a circle of twenty-seven miles from some familiar point. Incredible as it may seem, every point within this imaginary boundary would be within range of this gun.
Great engineering skill Is displayed In de- signing guns with an extremely high-angle fire. [The shells from such guns climb to 127
THE FIGHTING ENGINEERS
great heights, and after describing a grace- ful parabola, drop with wonderful accuracy upon the target. In defensive work along our seacoasts such batteries are, of course, likely to be more effective than more power- ful guns of longer range. The idea is to have the shot strike vertically, or as nearly so as possible, upon the deck of a ship. Since such shots are more likely to cause in- ternal explosions than is direct fire. The mortars used in seacoast forts usually con- sist of batteries of four guns, which are fired electrically. Four shots may thus be fired simultaneously, or two of the mortars may be set off singly by touching a button. The man behind the gun must be a highly tech- nical engineer, with all his forces, trained by long schooling, constantly on the alert.
The complete field-gun consists of two parts : the gun, and its limber or caisson, the latter carrying the ammunition. In action the two parts stand side by side. The method of serving field-guns has been made familiar to the most peaceful citizen through the medium of the motion-picture. Every one has seen the guns brought forward, — 128
THE MAN BEHIND THE GUNS
often with hysterical speed, — loaded, sighted, and discharged, while courage, daring, or fear are "registered" by the hard-working actors.
The patron of the ''movies" need scarcely be told that modern field-guns do not recoil with each shot and have to be hauled back into position. The gun is aimed by means of a telescopic sight. The carriage is fixed in position by means of a spade, at the end of its tail, dug into the ground. The shell is in- serted in the open breech, which is then closed and locked. The gunner pulls a lan- yard, there is a flash from the muzzle, and the gun springs backward. By beating on a drumlike instrument somewhere back of the screen the illusion is made complete.
The action is probably too quick to be caught by the eye ; but in this fraction of time the gun compresses a coiled spring, while the main force of the kick is taken up by a cylin- der filled with oil and water. A moment la- ter the spring forces the gun back, sliding it on its fixed carriage, or base, to its original position, where it may be sighted and fired without loss of time.
129
THE FIGHTING ENGINEERS
.There is important economy of time in using modern cartridges. The metalHc cases are slipped into position in a flash, the breech-block being operated by a single ac- tion. An ingenious device throws out the empty cartridge-case. Some cartridges are placed beside the breech in their original package, and are pushed into position with- out being touched by the hand, thus keeping them free from dirt or grease. Compare this method with the violent exertion of swabbing out the old-fashioned breechload- ers and ramming home the shots, the charge of powder, and the bullets. Our gunners can fire fifteen shots to a minute with these guns, while in France constant practice en- ables a gun-crew to fire twenty times a min- ute.
The machine-gun, which, by the way, must not be confused with revolvers or magazine- rifles, was used in our Civil War in more than a score of different forms. Little prog- ress was made in developing it, however, un- til about 1870, on the appearance of the new torpedo-boats. The rapid movement of the new craft eluded the guns of that period, 130
THE MAN BEHIND THE GUNS
and the ordnance engineers set to work to invent some new gun to overcome this advan- tage.
The early machine-guns had from six to ten bores, which revolved around a central shaft. Each shot had to be fired by hand, the gun being operated by turning a crank. It was at best a cumbrous method. Al- though the idea of utilizing the recoil of the shots to fire a gun was old, it was not suc- cessfully utilized until the appearance of the Maxim gun.
The machine-gun has had a wonderful de- velopment in the last few years. The older forms of rapid-fire gun have been completely outclassed. The gas-operating type of gun made and used in the United States appears almost magical to the layman, as, indeed, it would have appeared to the trained soldiers of another generation. It is an air-cooled gun, which is operated automatically by the escape of gas after each explosion. The gas escapes through a port a short distance from the muzzle and sets in motion the compli- cated machinery that operates the gun. As long as one holds back the trigger, the gun 131
THE FIGHTING ENGINEERS
discharges at the rate of from 450 to 500 shots per minute. A small battery of such guns fires as many shots as a regiment of men.
The cartridges — hundreds of them — are fastened to a woven canvas belt, which is fed into the gun with bewildering speed. When the gas, after each explosion, passes through the port, it acts on a piston which moves a lever, and the sharp impulse of the gas is instantly transmitted to a train of lev- er-springs and feed-wheels, all working in amazing harmony. As each cartridge comes into position, it is plucked out of the belt, delivered to a carrier, raised into position, and the cartridge-chamber is closed, ready for firing. On being discharged, the cart- ridge is thrown out and a new one takes its place.
Imagine the delicacy and precision of the mechanism which performs this complicated operation almost ten times in a second and keeps up sustained action indefinitely. By way of comparison, it is interesting to recall that the first guns used in warfare, which were adaptions of the ancient crossbow and 132
THE MAN BEHIND THE GUNS
were "loaded" by winding-up devices, re- quired about half an hour to wind up or load. Battles were fought in which only seven rounds of shots were exchanged.
A few years ago a gun of any size without some recoil would have seemed impossible. With the development of the aeroplane the makers of ordnance busied themselves to design a weapon that could be discharged aloft. The balance of an aeroplane is, of course, so delicate that the recoil of an ordi- nary gun, even a small one, might mean a fatal plunge. For some time the problem presented to the gun-makers proved baf- fling, but the advantage of directing artil- lery-fire from the air is so great that the en- gineers of ordnance returned again and again to the task. Until a good non-recoil gun was invented, a machine-rifle was the largest piece of ordnance an air man dared carry aloft.
In the first type of non-recoil gun the weapon was fired to the rear. When dis- charged in the air, the gun fell and was lost, so far as that particular flight was con- cerned. This proved an expensive method 133
THE FIGHTING ENGINEERS
of aerial attack. The present non-recoil type of gun is a marvel of ingenuity and workmanship. In a word, it consists of two guns, firing two projectiles, which exactly balance each other. The recoil of one gun cancels that of the other, so that the delicate balance of the aeroplane is undisturbed. With this invention, the aeroplane suddenly became an efficient weapon of attack.
This aero-gun is, in reality, a double-bar- relled or, more accurately, a double-length gun. Placed end to end, ready for firing, it appears to be a very long, single-barrelled gun. The two guns have the same bore, so that when discharged breech to breech, the force of the recoil exactly balances. Two projectiles are fired in opposite directions. A steel shell leaves the forward barrel, speed- ing toward its target, while the second pro- jectile speeds toward the rear. A man di- rectly behind the gun would occupy a dan- gerous position.
The cartridge fired from the front barrel is of the conventional form used in ordinary guns. The rear barrel fires a charge of wad- ding which breaks up, losing its initial veloc- 134
THE MAN BEHIND THE GUNS
ity in a few feet. By the time the wadding has fallen to the ground it becomes entirely harmless, and even if it should chance to hit some one, no injury would result. This highly ingenious form makes it possible to build guns firing two-, six-, or twelve-pound cartridges, weighing from 60 to 210 pounds. The muzzle-velocity of these shots is in ex- cess of 1000 foot seconds. The aeroplane can thus carry aloft a battery of cannon which, as regards bore and efficiency, enor- mously increases their deadliness.
One of the most interesting forms of mod- ern ordnance is the anti-aircraft gun that has appeared in very recent times. An aeroplane in flight naturally is an extremely difficult target to hit. It moves at a rate of 100 miles or more an hour, and often at an altitude of one or more miles. Its course may be a rapid zig-zag, which greatly adds to the problems of the gunner. The extreme range of these anti-aircraft guns is about 21,000 feet, or about four miles. When fir- ing directly upward, the shot requires about twenty-two seconds to reach its destination. The gunner must therefore calculate the 135
THE FIGHTING ENGINEERS
speed of the aeroplane and aim his gun in advance of it in such a way that it will in- tercept its course almost half a mmute after the gun is fired. Such guns obviously fire shrapnel.
Air defense remains one of the unsolved problems of the war. The anti-aircraft guns are marvels of ingenuity, but the prob- lem they must face is extremely difficult. Much progress has been made, and the guns are to-day so effective that the Zeppelin has been practically driven from the skies. By night such work is greatly complicated. The most powerful searchlights can do little to pick out aircraft several miles high. The discharge of the batteries drowns the sound of the aeroplane's propellers. Such guns, of course, can be readily aimed at any angle and, despite their size and weight, are extremely mobile. The gims are often mounted on motor-trucks that may be rushed from point to point at top speed.
The aeroplanes that raid London as a rule
reach England somewhere above the mouth
of the Thames and follow the line of that
river. When the approach of a hostile fleet
136
THE MAN BEHIND THE GUNS
is discovered, a barrage is put up at the mouth of the Thames. This usually proves very effective, and it is believed that one half the attacking fleet is often brought down at this point. In using anti-aircraft guns above any city, there is danger, of course, that the shrapnel will fall back, and, gaining immense momentum in dropping several miles, inflict damage upon friends. It is commonly said that everything that goes up is Allied, while everything that comes down is Boche.
A complete revolution in artillery methods may follow the invention of guns of such ex- treme range as are now being employed by the Germans in the fourth year of the Great War. In the spring of 1918 the world was startled by the announcement that shells dis- charged from German guns had reached Paris, inflicting loss of life. The first re- ports were discredited, so impossible did such a bombardment appear. It was esti- mated that such shells must travel for more than seventy miles, or nearly four times as far as the most powerful guns heretofore used. The continued long-range bombard- ^Z7
THE FIGHTING ENGINEERS
ment of Paris, with considerable loss of life, soon convinced a sceptical world, however, that a seventy- or perhaps eighty-mile gun was in operation.
Although the secret of these guns has been closely guarded, it is known that their bar- rels are about sixty feet in length. The shells fired measure eight and one quarter inches in diameter. The empty shell weighs 330 pounds, and the charge has the same weight. The projectile rises to a height of 18.6 miles and then descends from the sky, gaining velocity as it falls. By climbing to this height the shell, of course, reaches rare- fied air. This is said to simplify the prob- , lem of throwing it this immense distance. It is estimated that the shell requires more than three minutes to reach its target.
The Lewis gun depends for its marvelous speed in firing upon the tension of springs acted upon by the force of exploding gas. Although weighing only twenty-one pounds, it will fire from 400 to 700 shots per minute. Its action is entirely automatic. The car- tridges are arranged in a spiral shell that holds fifty rounds. This shell can be re- 138
THE MAN BEHIND THE GUNS
placed in two seconds. The gun is cooled by means of a long tube of aluminum, along which air is drawn.
Doubtless the most mobile batteries in service are the motor-cycle machine-guns. The English army alone has thirty thousand machine-guns mounted on motor-cycles. Over any passable road these motors can cover thirty or forty miles an hour, or better, and therefore prove indispensable in support- ing infantry. The cyclists are daring riders, and hundreds of such guns may be brought into position with bewildering speed. A company is often rushed forward to hold a position until reinforcements arrive. The machine-guns may be fired from the motor- cycle by using a rigid tripod. Distance is covered so quickly by the motor-cycles that repair-shops are usually placed well in the rear.
The most completely equipped motor-bat- tery in the service to-day is said to be the Ninth Heavy Field Artillery of the United States Army. Motor-tractors of many forms have completely superseded the horse- drawn units. The colonel of a regiment 139
THE FIGHTING ENGINEERS
travels about the field in a light automobile, thus keeping in touch with widely separated units with the least possible delay. Officers travel rapidly in motor-cycles equipped with ''bathtub" side-cars. A complete equipment of motor-trucks, driven by all four wheels, are used to rush up ammunition and supplies of every kind. The heavy guns are drawn by "caterpillar" tractors, which trundle slowly but surely over ground that would be impossible for horses. The tractor part of a regiment's equipment includes forty-five machines. One of the great advantages of these tractors is that much heavier guns may be drawn into action than is possible by the use of horses. Such equipment replaces at least one thousand horses that would other- wise be required for each regiment.
The work of arming millions of men with rifles is one of the main engineering prob- lems of war. Several rifles are turned out, complete, for every man in the ranks. In all these millions of weapons the greatest accur- acy of every part must be assured, and the fabrication of the parts requires a high de- gree of technical skill. The barrel is the 140
■^y
i hi
©
THE MAN BEHIND THE GUNS
most difficult problem. At present the ma- terial most favored is smokeless barrel-steel, which is found to resist the corrosive action of the gases set free by the explosion.
The methods of manufacture vary consid- erably. A common method is to cut a rod of uniform diameter, and then upset one end and thicken it to form the breach. Some barrels are rolled by special machinery, in or- der to get the proper taper. The barrels are next roughly straightened. The boring is done by rotating the barrel at high speed, while the metal is cooled and lubricated by a stream of oil, after which the bore is smoothed. It is so vital that the bore be ab- solutely straight that the work must be done by experts, with the greatest precautions. The barrel is ground on a grindstone, and then is repeatedly tested with a bullet. The rifling comes next, when the bore is cut with the grooves that give the bullet its rotary motion on being discharged. The rifle is then ''browned," as it is termed, by a chemi- cal bath, although its color, as all the world knows, is really a dark blue.
Before leaving the factory every rifle is 143
THE FIGHTING ENGINEERS
subjected to a high-powder test. A heavy leaden plug is driven into the muzzle, and a charge equal to two or three times any nor- mal charge is exploded. Such a rifle may be discharged 250,000 times without losing its accuracy.
The general public has no conception of the difficulties that face the engineers of the ordnance department in constructing vast supplies of guns and ammunition. It has been necessary to supply our troops with 100,000 different items, ranging from the tiny firing-pin of their rifles to the complete 16-inch gun with its emplacement. One of the great guns mounted on a modern disap- pearing-carriage consists of 7,990 parts, not including the sights and accessories. Even a 3-inch gun-battery requires 3,876 different tools, accessories, and supplies. For every gun in use there must of course be a reserve supply of all parts. Since hundreds of thou- sands of such guns must be supplied in "rush time," new engineering problems must be solved in quantitative production.
It has been necessary to build new plants on an unprecedented scale, finance them, and 144
THE MAN BEHIND THE GUNS
assure an enormous production in the brief- est possible time. In times of peace the Government directed eleven small arsenals. Within a few months it directed the output of 14,000 private manufacturing establish- ments. A great army of workers is em- ployed to turn out shells of all calibers, rifles, ammunition, grenades, and bombs. The housing of these supplies alone presents a serious problem, since more than 23,00,000 square feet of storage-space will be needed for such supplies. An efficient system of handling supplies has been worked out by army engineers, and this has necessitated the building of hundreds of miles of special railroads. More than 10,000 carloads of explosives, for instance, are handled every month.
In the first year of our participation in the Great War the Army Ordnance Department increased its staff from ninety-seven to over 5,000 officers, a large proportion of whom are highly skilled engineers. Its expendi- tures during our first twelve months in the conflict aggregated $4,756,500,000. The output of rifles was increased to 45,000 a 145
THE FIGHTING ENGINEERS
week, and during the past year 1,400,000 guns were supplied. The delivery of ma- chine-guns was increased from 20,000 to 225,000 a year, while the output of field-guns of all types was jumped from 1,500 to 15,000 a year.
146
CHAPTER VIII
MODERN SHELLS AND ARMOR
THE old-fashioned, cast-iron cannon- balls, which we see piled in neat pyra- mids in public parks, are as obsolete as the guns that used to fire them. They have been replaced by a complicated contrivance of steel some thousands of times more effective than the old missiles. The deadliness of the shell is immensely increased by a secondary charge of bullets, — several hundred of them, — which are scattered by a second explosion, much the same as a rocket explodes after a long flight. The base of the shell carries a charge of powder and several hundred bul- lets, the interstices being filled with a smoke- producing mixture. A time-fuse is ar- ranged at the nose of the shell, which may be set with reference to the range and the time of flight, so that the powder will explode when the shell nears its target, usually when 147
THE FIGHTING ENGINEERS
above a body of troops. The time-fuse must be constructed with mathematical accuracy, — in order to measure the time in minute fractions of a second.
The fuse-device in a modern shrapnel shell and in a high-explosive shell contains mar- velously delicate mechanism. There are shearing-wires, centrifugal bolts, safety- pins, needles, and hammers adjusted with the utmost delicacy. Although these shells are capable of destroying every object in their vicinity, they are perfectly harmless until the safety-pins are removed, when their complex mechanism is permitted to function. The safety-pins resemble the familiar domes- tic articles only in name. A generation ago the soldiers often cast their own bullets and cannon-balls by melting lead and pouring it into crude molds. To-day a scientific metal- lurgist is required to prepare the materials. Some knowledge of chemistry is required, even to read the formulas that describe their composition. Every detail of the work is highly specialized.
The shells must, besides, have just the right hardness, for if they are too brittle, 148
MODERN SHELLS AND ARMOR
they may be shattered in the gun, and if too soft, they will bulge and widen before leav- insf the barrel. The most minute detail is of vital importance, for the period of explosion must be brought within absolute control. The balls in such a shell are discharged from their case with an additional velocity of from 250 to 320 feet per second. These guns have a range of several miles, and so delicate and accurate is this mechanism that the point at which they will explode may be determined within a few feet.
Among the most complicated of these mis- siles are the aerial bombs dropped from air- craft. It might be supposed that any con- tainer loaded with an explosive would prove sufficiently deadly when dropped from an altitude of two or three miles, — but engineers have succeeded in greatly increasing its dead- liness.
The cross-section of such a bomb appears hopelessly complicated to the layman. The mechanism is so arranged that a drop of fifty feet starts its extremely complex machinery. A small propeller at the end of the bomb is spun by the resistance of the air, and this sets 149
THE FIGHTING ENGINEERS
the involved machinery going. The aviator, having calculated his altitude, the speed of his aircraft, and the resistance of the wind, and having solved a rather difficult equation, determines how long his missile will take to reach its target. The time-fuse in the nose of the torpedo is set accordingly, then re- leased. In the fraction of time taken for the heavy bomb to plunge down to the earth the machinery functions with scientific pre- cision. A plunger is released, which brings the chemicals together, a primer is fired, and at a prearranged distance from the earth the bomb explodes. Before these time-mechan- isms were employed a great deal of energy was lost, since the bomb only exploded on striking its target, and was likely to plunge deep into the earth, where it could do com- paratively little damage.
New figures of speech must be found to describe the unprecedented volume of sound in modern cannonading. Cannons no longer "thunder." Never before have so many guns of great caliber been massed together or served so continuously. Observers, both on the Allied side and the German, have re- 150
MODERN SHELLS AND ARMOR
marked the peculiarly impressive roll that follows the discharge of a high-powered gun. This sound is heard to best advantage in rug- ged land of irregular contour, well-wooded and set with many buildings. The report of the cannon is followed by a majestic, echoing roll, which has been described as like a great brass orchestra, with a more distinctly musi- cal note than thunder. The report is fre- quently mistaken for the actual roar of the shell, while in reality it is produced by the combined echoes from thousands of recesses and inequalities in the earth over which the shell passes.
One of the curiosities of the war is the tricks of acoustics played on the gunners and the enemy in artillery duels. It is a well-known law of acoustics that intensity of sound grows less in proportion to the square of the distance. Double the distance, and the sound has but one fourth its original volume. We are likely to apply this rule in- stinctively when locating or comparing any sound.
To the bewilderment of the soldiers at the front, the enemy's guns often sound much 151
THE FIGHTING ENGINEERS
louder than their own batteries. Men well behind their own cannon have often been alarmed to hear the attacking guns sound much more formidable than their own. The evidence of their senses would seem to tell them that the enemy's battery was the more powerful.
The explanation is simple. Sound is con- centrated in the direction of artillery fire. The reports of these great batteries, heard from the rear, merge into a great, dull roar of incredible volume. The reports from the guns aimed directly at one have a sharp, staccato note, although the guns may be of similar type. It is this sharp, staccato note that has been frequently compared to the tattoo of a giant drum. During the bom- bardment on an unprecedented scale of the massed Allied artillery on the Somme, the Germans described this curious phenomenon as trommel feuer, or drum-fire, and the phrase has come into general usage.
The destructive power of the great guns has been carefully measured. The seven- teen-inch howitzers, which hurl shells filled with explosives weighing 2800 pounds a dis- 152
MODERN SHELLS AND ARMOR
tance of twenty-four miles, are practically irresistible. No structure nor fortification has yet been devised that can withstand such a blow. One of these shells has penetrated a barrier of twenty-six inches of steel armor, backed by twenty feet of solid oak timber, and then a thickness of twenty-one feet of granite and concrete masonry, making a total of forty-three feet of the hardest materials that can be assembled.
As the weapons of warfare have become more deadly of late, several forms of armor, long ago discarded, have returned. A sol- dier of the Middle Ages, who had never heard of gunpowder or firearms, would find the trenches, with their steel-helmeted sol- diers, a familiar sight. The gas-mask bears a faraway resemblance to the visors that pro- tected the knights of old. Within a few years the appearance of the fighting man has been transformed, and if the war should continue and new^er and more deadly missiles be invented, modern armor may assume un- expected forms.
The soldiers of Rome and Greece wore no armor, except the shields they carried to 153
THE FIGHTING ENGINEERS
ward off the blows of spears. As side-arms and the lower-power projectile came into use, the complicated armor of the Middle Ages gradually developed. To ward off at- tacks of crossbows or javelins, the soldiers first wore thick garments of skins and furs, and then came the helmet and cuirass.
The period of armor reached its complete development by the middle of the fourteenth century. The soldiers then fought under a heavy weight of metal, so that often it was necessary for a knight to be accompanied by a follower to assist him to carry his fighting equipment. The legs and arms of the mounted men were protected by steel plates, the hands by articulated gauntlets, and the feet by iron shoes. It was impossible for men on foot to carry such armor, and they were less well-protected. They wore hel- mets, shoulder-pieces of metal, shields, arm- and thigh-pieces, a protective piece for the knees, and short coats of mail.
The use of gunpowder quickly changed
the appearance of fighting men. In a period
of ten years, as firearms grew more effective,
most of the protective armor disappeared.
154
MODERN SHELLS AND ARMOR
The saving in weight of equipment that men had to carry into battle was, of course, an enormous gain. Warfare was revolu- tionized. Instead of converting each man into a movable fort, as it were, every effort was now made to gain individual invisibility, and the familiar service-uniform next ap- peared.
To-day, with steel helmets, gas-masks, and spectacles, we are, in a measure, returning to the ancient methods of protection. The first form of this modern protective headgear in the present war consisted of metal caps worn under the kepi, which assured ordi- nary protective covering. It was found, however, that this headpiece caused head- aches and other discomforts, and its conven- ient form often tempted the soldiers to use it as a cup or a cooking-utensil. The pres- ent form of helmet has gradually evolved. It is designed along scientific lines, so that a missile striking it, even at an angle of fifty degrees, will glance ofif .
The steel helmets worn by our soldiers in France afford a unique problem in engi- neering. Four fifths of all the casualties in 157
THE FIGHTING ENGINEERS
modern warfare are head wounds. The protection of the soldiers' heads, therefore, becomes a matter of supreme importance. Profiting by the experience of the British, French, and Germans in designing these steel protections, American engineers have im- proved upon earlier designs. The helmet worn by American soldiers follows the gen- eral lines of the British type of inverted *'soup-plate," rather than the French ''casque" or the German "coal-scuttle." Penetration tests show that no helmet is more efficient than that of the American type. Every helmet issued to the American sol- dier has passed a severe test and is absolutely free from cracks or flaws. To turn out this complicated headgear by the million, using only the highest grade of materials, is a big order ; but the great manufacturing resources of the United States have proved equal to the work of quantitative production. Steel hel- mets had never before been made in the United States; but new machinery was de- signed, and the supply has never fallen be- hind the demand. The helmets are made by stamping and punching sheets of steel, so 158
MODERN SHELLS AND ARMOR
that thousands may be turned out in a day, with great saving of labor. Each steel sheet is one foot square and one Syixth of an inch thick. The pieces sheared off and other wastage are returned to the Government, so that nothing is lost.
Careful tests are first made of each sheet, to determine if it is free from flaws. The lives of thousands of men depend upon the thoroughness of these tests. Each sheet is then placed between "male" and "female" dies, and under enormous pressure it is forced into the familiar shape. The process is accompanied by a piercing shriek from the steel. The next machine cuts away the edge, or brim, with a single blow. An electric welding apparatus is used to join the parts and smooth the rim.
It is important that the steel be colored, so that it will not reflect the light and thus make a conspicuous target for the enemy. The French color their helmets blue, while the British sprinkle sand over theirs. The American helmets are treated with a secret preparation that kills reflection and at the same time is a poor conductor of heat. Our 159
THE FIGHTING ENGINEERS
helmets are finished by inserting a special lining that keeps the head from touching the steel sides and absorbs the shock of all im- pacts. The American helmet, complete, weighs less than two pounds.
Since the adoption of these helmets the number of cranial wounds has considerably increased, but a large proportion of such wounds are curable. Before a helmet was worn, fewer men Were treated for cranial wounds, for the simple reason that wounds of this nature were usually fatal. The latest form of helmet that has been found in cap- tured German trenches is designed to resist even direct rifle-fire. It is made of Krupp steel one fourth of an inch thick, which makes the head-piece too heavy to be carried about. These helmets have only been picked up in first-line German trenches, and it is supposed that they are only worn when the men are on duty, to protect them against snipers.
Many engineers in America and Europe believe it possible to construct a bullet-proof shield or cuirass sufficiently light and port- able to be made part of the modern soldier's 1 60
MODERN SHELLS AND ARMOR
equipment. Several years ago it was thought that the problem had been solved by a German inventor who devised a shield the height of a man, consisting of four or six hinged parts that could be rolled up and car- ried about with ease. It was found to suc- cessfully resist bullets fired only twenty- three feet away. Before any general use could be made of the invention the penetrat- ing power of bullets was increased, and the shield proved useless, except to turn aside glancing blows or pieces of shrapnel.
A later plan has been to make the cuirass of steel covered with special padding of cot- ton, over which, in turn, is placed thin metal bands. A flexible cuirass has been made of a series of metal spheres held together by hooks and eyes. Still another plan is to build up a resisting fabric by means of a series of hollow metal balls. A French inventor has devised an elastic cushion, a combination of springs and sockets filled with rubber. The theory of these cushion-formations is that the bullet will embed itself without penetrat- ing, the force of the impact being taken up before the missile passes through the fabric. i6i
THE FIGHTING ENGINEERS
Many designs have been suggested for ap- plying such protection. It is urged by some that it be used exactly as were the metal plates in early armor, or that portable buc- klers or shields be fastened by leather brace- lets to the left arm of the soldier and used in an advance as a shield.
Many military authorities also believe that great advantage may be gained by utilizing the knapsack carried by soldiers, his en- trenching tools, and even his clothes for de- fensive purposes. Many forms of knap- sacks have been designed to resist bullets and shrapnel. When fully loaded they of- fer considerable resistance. By placing them upright, a miniature breastwork is formed that protects the soldier from ordi- nary rifle-fire. Scientific tests have been made with various forms of knapsacks by firing at them from different ranges. It was found that two knapsacks placed together would resist forty per cent, of all balls fired at them from a range of eight hundred paces. The metal tools used by the infan- try, and especially by the engineering regi- ments, are also used with good effect. A 162
MODERN SHELLS AND ARMOR
trench-spade driven into the ground and backed with a few shovels of earth often proves surprisingly effective. The ingenu- ity of the engineers now fighting at the front is expected to devise many new forms of pro- tection.
163
CHAPTER IX
AMERICAN VERSATILITY
THE great industrial army recruited in America will comprise some forty regi- ments, elaborately equipped for service in France. Within a year the engineering forces of our army have been increased 1660 per cent. Meanwhile the purchasing power of the Engineer Corps has been raised 2250 per cent. During the first three months of mobilization the General Engineering De- pot spent $175,000,000, and during the fiscal year the total was about $375,000,000. The cost of the Panama Canal, which heretofore was the high-water mark for all engineering expenditures, seems trifling by comparison. This immense budget has made possible the designing, specification, purchase, gathering into central depots, and forwarding of all en- gineering materials and equipment supplied 164
f-
AMERICAN VERSATILITY
our army, as well as all engineering opera- tions in the field.
The names of the regiments of engineers already recruited will give some idea of the energy and versatility of these forces. The classification is as follows :
Water-Supply Mining
Highway Quarrying
Light railroading General Construction
Standard-gage Rail- Engineers' Supplies
roading Surveying
Gas and Flame Army and Pontoon Forestry Post
When America entered the war France designated certain seaports for the exclusive use of the ships landing our armies and sup- plies. Our engineers found these were tidal ports, and special docks had to be built to ac- commodate the unprecedented demands of our fleet. The work was handed over to the engineers, who quickly prepared complete plans for building elaborate docking facili- ties.
These docks were fabricated in America 167
THE FIGHTING ENGINEERS
and sent to France to be placed in position. Every detail of their construction was pre- pared on this side of the Atlantic, including the piles for the docks, the flooring, and houses for the protection of men and provi- sions. An immense amount of machinery for handling heavy weights, including many powerful cranes, was designed to meet the peculiar demands of this work. With the aid of these American-built docks and ma- chinery, the enormous task of disembarking an army of hundreds of thousands of men has been carried on without mishap.
A favorable impression has been made in France by the system of repair-shops built and operated by American engineers. The steel for many buildings was prepared in the United States in an incredibly short time, and put together in France with a speed that suggests the erection of Aladdin's pal- ace. An order was placed in America, for instance, for 4000 steel hangars, measuring 68 by 165 feet, each to house four aeroplanes. This order was executed in less than sixty days. The field repair-shops, incidentally, 168
AMERICAN VERSATILITY
are usually placed as near as possible to the front to save time in transporting broken ma- chinery. They are never built close to- gether, but at intervals of a half-mile or more, so as to offer an inconspicuous target.
Equipped with American machinery and manned by skilled workmen, these shops are prepared to mend every conceivable form of fighting-machine. The guns, large and small, require constant attention. Should a great gun get out of order, every moment of delay in bringing it into action may be priceless. Again, the tens of thousands of automobiles behind the front require con- stant repairs. The life of some of the more delicate aero-motors proves to be only about forty hours at the front, after which they must be reground.
In recruiting these engineering regiments every conceivable service seems to have been anticipated. The engineering regiments in- clude a number of expert workers on bicy- cles. From the tons of litter picked up on the battle-fields, the broken parts of bicycles are carefully sorted out and put aside. 169
THE FIGHTING ENGINEERS
Many of the wheels used have been stand- ardized, which simplifies the work. The wrecks of wheels that seem beyond hope are combined in order that nothing shall be wasted. Companies of motor-cyclists use up their wheels very quickly, and by keeping the workers busy, thousands of wheels are reclaimed. There are, besides, many hos- pitals for broken rifles, where injured weap- ons are repaired or parts of guns are stored for future use. The saving that results from this scientific economy amounts to mil- Hons of dollars a year.
As might be expected, the electrical indus- tries of America are well represented in the engineering regiments. Several of the larg- est manufacturing plants have sent their of- ficials, who are well-known engineers, while hundreds of experienced workers in every branch of constructive work have volun- teered. These American units are prepared to take over bodily every imaginable electri- cal enterprise, install a new system or oper- ate an old one, without an hour's delay. So many American inventions are in common use abroad, and the French have made such 170
AMERICAN VERSATILITY
general use of our electrical machinery, that American electricians report that they find themselves much at home in the work.
An immense amount of electrical work must be carried on at the front and imme- diately behind it. Great distributing sys- tems for operating electric-lights and sup- plying power have been established and op- erated in the war zone. A large and uni- form supply of current must be provided for headquarters, cantonments, artillery repair- shops, and hospitals, as well as for the air service and the reconstruction bases. If, through any carelessness or inefficiency, the power should be cut off for a single hour, the loss would prove serious. Again, a well- directed shot may at any moment of the day or night destroy conduits vital to the ma- chinery, and repairs must be made, however difficult the conditions, with the greatest ex- pedition. The linesmen, as well as the en- gineers, in the electrical stations near the front frequently perform highly technical work while under fire.
The ingenuity of our engineers has proved valuable in the conservation of electrical 171
THE FIGHTING ENGINEERS
power in many cities and towns in France. The electrical industry has often been de- moralized, especially in cities near the front. Thousands of Frenchmen have had to go to the trenches, and production has conse- quently suffered. American engineers have accomplished marvels in meeting this power- famine. In some localities the electrical system has been completely reorganized. Important plants have been combined, and all unnecessary waste has been eliminated.
The allotment of power to street-cars and for street-lights has been systematically re- duced, in order that manufacturing indus- tries essential to the war might not suffer. In some sections a census has been taken of all the electrical machinery, so that every part may be utilized. The new power-plants constructed and the system installed by intro- ducing the latest American methods will prove of great permanent value to France.
The engineers of the Signal Corps often have to face great peril. Telephone com- munication is so vital a matter at the front that communicating lines of wire must be laid at any cost. When an advance is pre- 172
AMERICAN VERSATILITY
pared, the telephone linesmen, with their material in hand, are held in readiness. They carry an ample supply of heavily in- sulated copper telephone-wire, — for the lines are often run along the ground, — with their equipment for setting up a loud-speaking telephone. First the heavy artillery-fire pre- pares the way and sweeps the front trenches of the enemy. Heavy smoke-bombs are then thrown to conceal the advance, and at a sig- nal the men go "over the top."
The signal-men follow closely. They carry reels of wire, which they run out as they struggle forward. If a linesman falls, another takes his place. There is no time, as a rule, to arrange supports for the wire, and in the barren wastes of no-man's-land no tree nor stick remains to which to attach them. The wires are run rapidly from point to point, until the field is covered with a network of communicating lines. A chance shell from the enemy may destroy these wires at any moment, when the work must be repeated.
Such work is often complicated by lack of supplies. In a hurried advance the electri- 173
THE FIGHTING ENGINEERS
cal equipment may be lost, and the signal- men must then work with whatever make- shift material they find at hand. An engi- neer, finding himself one day on a battle-field hopelessly far from his base of supply, im- provised a working-station entirely of waste material. A switchboard, capable of serv- ing five stations, was contrived entirely from material picked up on the battle-field. The metal was supplied by an eighteen-pound cartridge-case. This was fastened to boards with screws taken from ammunition-boxes. The plugs consisted of .303 rifle cartridge- cases, and fuses and pieces of picked-up wire completed the installation.
As the infantry advance, it is of vital im- portance that the heavy batteries far in the rear be informed of their progress and their exact position. The signal-men rush for- ward, the wires are connected with the in- struments they carry, and news of their prog- ress is sent to the batteries at the rear. Ar- tillery fire can thus be directed from a posi- tion perhaps miles at the rear ; otherwise the shells might fall alike on friend and foe.
Few of the fighting engineers face greater 174
^ '4
=r- n '
AMERICAN VERSATILITY
danger than do the men recruited for the Gas and Flame Regiment. As the name suggests, these engineers direct the work of producing liquid fire, which is employed be- fore an attack. These men must be expe- rienced chemists, and the preparation of in- flammable solutions is left to them. Streams of burning oil are often shot forward a dis- tance of 150 feet.
The Gas and Flame Unit is officially- known as the Thirtieth Engineers. In en- listing this regiment, men between the ages of eighteen and forty-five have been taken. Every member was obliged to have some technical experience which fitted him for the work. The regiment, therefore, includes chemists, mechanical engineers, explosive gas-workers, electricians, gas-experts, me- chanics, pipe-fitters, and special interpreters. The regiment was quickly mobilized as early as October 15, 1917, and was sent to Camp American University under command of Major E. J. Atkinson. A number of Eng- lish officers who were experienced in the work, were sent over to train them.
One of the engineering regiments includes 177
THE FIGHTING ENGINEERS
a company of twenty "skyographs," a serv- ice new in warfare. These men, who are ex- perts in their profession, are employed to analyze the bird's-eye photographs taken by aeroplane scouts. From long training, they are skilful in constructing the military maps used in planning campaigns and directing military operations. The aero-photograph- ers fly regularly over the lines, and take thousands of photographs from various ele- vations with the aid of special aero-cameras. Such photographs are then compared with the maps of the region, and the information available and everything of military impor- tance is indicated upon them. A few hours after the pictures are made, a general, per- haps miles behind the lines, by the aid of such map-photographs may be said to look directly down upon the enemy.
The varied experience of American bridge-builders has proved a valuable asset. The regiment recruited in the United States for this work is officered by a number of en- gineers selected from railroad companies, the Army, and official bodies, while the rank and file is made up of men trained by years of ex- 178
AMERICAN VERSATILITY
perience in actual construction work. With such a force, every problem abroad may be attacked with confidence. Widely scat- tered over Northern France, American en- gineers are to-day actively engaged in build- ing a variety of bridges, great and small.
Compared with European standards, American engineering work sets a fast pace. In the present operations every effort has been made to improve upon our own best records, often with amazing success. Un- loading of ships in France has been speeded up, so that the work is being done to-day in less than one third the time usually required. The first order in America for standard-gage locomotives of the ninety-ton type, calling for three hundred units, was placed on July 19, and delivery was required in October. The first locomotive was delivered, complete, on August I. This was followed by a second order for 680 locomotives of the same type.
In some respects the most notable construc- tive work of the American engineers is the great ordnance base ''somewhere in France." It is really an industrial city in which every unit is carefully organized for constructive 179
THE FIGHTING ENGINEERS
work. The cost of building this plant is esti- mated at $25,000,000, while the tool equip- ment cost is an additional $5,000,000. The plant includes twenty large storehouses, twelve shop-buildings, and one hundred smaller shops and magazines.
One of its important features is a great gun repair-plant, equipped to handle more than 800 field-guns of all sizes each month. In connection with this is a gun-carriage repair-shop of large capacity, where 1200 vehicles may be repaired monthly. The small-arms repair-shop has a capacity of 50,- 000 small-arms and machine-guns a month. Furthermore, there will be a large shop for repairing horse and infantry equipment. The reloading plant is capable of renewing 100,000 artillery cartridge-cases a day. In connection with this tremendous activity there are innumerable forges, carpenter- shops, and auxiliary buildings. A popula- tion of 16,000 men and 450 officers is re- quired to carry on this base. More than 8000 men have already enlisted in America for the work, and the training of these highly technical troops is progressing rapidly. 180
AMERICAN VERSATILITY.
The Allied governments have been amazed at America's facilities for turning out steel and iron constructive material. In build- ing thousands of steel structures throughout the country the number of constructive plants has been greatly increased in recent years, and the time required to fill orders has been cut far below European standards. The facilities of such plants were well illus- trated in the filling of a recent order for one hundred steel warehouses. The buildings were to measure 50 by 400 feet, with a height of 16 feet below the trusses, the sides and the roofs to be made entirely of galvanized steel. Each building required 175 tons of steel. The order was received at the depot on a Thursday afternoon at four o'clock. By the following Saturday at four, — within forty-eight hours, — the entire job had been designed in detail, and orders for the parts had been placed with seven different fabri- cating shops. Seventy-five of the buildings were delivered, complete, in six weeks, and the remainder followed shortly. An order was recently filled for 750,000 sheets of cor- rugated iron, to be shipped at once. 181
THE FIGHTING ENGINEERS
On retreating from any occupied territory the Germans and Austrians often content themselves with destroying the central sup- port of a bridge, leaving the spans to fall to the bottom of the river or ravine, as the case may be. Such a bridge is restored in a sur- prisingly short time by rebuilding the central pier and raising the spans to their original position. The bridge-building engineers employ a make-shift pile-driver, which works with surprising rapidity. Power-plants are usually hard to find, but man-power is likely to be plentiful. A heavy weight is quickly rigged with pulleys, and a hundred or more men, pulling on the rope, raise the weight, then let it drop, forcing the pile into the earth with slow but steady blows.
Every detail of the work that can be pre- pared is, of course, done in advance. Not only are the plans made in detail for bridging a variety of openings, but bridges of vari- ous designs are built and then knocked down, ready to be carried away and put together again. For small spans, a steel bridge is sometimes used. This can be set up in dif- 182
AMERICAN VERSATILITY
ferent lengths. The parts are cut and drilled, so that when put in place they will fit as neatly as a puzzle. No riveting is re- quired, the parts being fastened together with bolts that may be driven with an ordi- nary hammer. Such bridges may be set up very quickly.
The engineering regiments are liberally supplied with expert photographers equipped with up-to-date apparatus. The skill and daring of the camera-man is proving invalu- able in a variety of war activities. In many cases the photographers form an advance- guard, and may be compared to the sharp- shooters or pickets who fight in advance of the main body. It often happens, for exam- ple, that the advance-guard will reach a bridge, or the site of a bridge, made unten- able by the enemy's fire. It may be impera- tive that the bridge-builders at once survey the location and make their plans for build- ing a new structure with the least possible delay. A deadly fire, meanwhile, may ren- der the position practically impossible. For the engineers to expose themselves, while 183
THE FIGHTING ENGINEERS
they examined the injured structure and made the necessary measurements, would mean almost certain death.
The alert camera-man, however, readily solves the problem. By slowly crawling for- ward, taking advantage of every tree and rock, or it may be by a rapid dash, he secures snap-shots of the bridge from one point of view after another, with the details of the approach. Such a set of photographs are well worth the risk. The exposed films are then rushed to the rear, to be developed and enlarged with the least possible delay. The prints serve as rough working-drawings from which the engineers, in this case the experienced bridge-builders, may calculate the size of the parts required to restore the bridge or to construct a new structure. The parts are quickly prepared and hurried for- ward, where a corps of engineers assemble them, and the chasm is bridged or the old structure is sufficiently repaired to enable the troops to advance. The fearlessness of the camera-men has thus saved many valuable days.
The camera serves the road-builders in 184
AMERICAN VERSATILITY
much the same way. If a raih-oad is to be laid, the photographers accompany the sur- veyors in advance of the workmen, and inci- dentally often face a very lively peril while working in disputed territory. The photo- graphs thus obtained show the engineers the nature of the ground to be traversed and as- sist them in preparing material in advance. The builders of highways have also learned to depend upon the camera-man. A section of road that is to be repaired, for instance, is photographed in detail from various an- gles. From this evidence the road-construc- tion engineers can readily determine the na- ture of material needed for repairs and can calculate the quantity required. When a road is projected across new territory the staff-photographers are first sent out to make detailed pictures of the ground. From these the engineers at the bases far in the rear may make their plans in detail. So much depends upon the highways in this war that the work of the camera-men in facilitat- ing such construction often proves invalua- ble. When any territory is to be evacuated, once more the photographers picture every 187
THE FIGHTING ENGINEERS
detail of the ground, the buildings, bridges, possible observation-posts, streams, and other natural features. If the country falls into the hands of the enemy, they thus retain an accurate, detailed record that will prove valuable to the artillery and to the aeroplane scouts in subsequent operations.
In no other country is the camera so com- mon as in America. In some form it is in the hands of all classes, even to the further- most corners of the land. Years of practice have served to develop a surprisingly high degree of skill in picture-taking. The Gov- ernment therefore draws upon an inex- haustible supply in recruiting men for pho- tographic work.
The fighting engineers so often find them- selves under fire that elaborate concrete shel- ters, or abris, are built at frequent intervals. These shelters are built of brick or concrete, with solid, concrete roofs two feet or more in thickness. They are practically shell-proof. The entrances are convenient to the roads, so that workmen may quickly find shelter. From long experience the engineers have come to think scarcely more of such fire than i88
AMERICAN VERSATILITY
they do of a passing thunder-storm ; and as soon as it shows signs of letting up, they hurry back to their work.
The rapidity with which a towering sky- scraper rises in the United States, or a **boom" town is built on a Western prairie, has been surpassed by the erection of the great cantonments throughout the United States. A more severe test of our resource- fulness than the building of these vast wooden cities could not be conceived. The order came as a complete surprise. No ma- terial was at hand, an army of skilled work- men had to be recruited overnight for the task, and every hour had to count in the work.
The task might have daunted Aladdin himself. Sixteen wooden cities had to be built, comprising 26,500 buildings, for the housing and care of 675,000 men; two em- barkation camps for 43,000 men; one quar- termaster's training camp for 18,000 men; additions to the regular army barracks for 100,000 men; repair shops, units and their structures at sixteen National Guard camps to care for 462,000 men; and many large 189
THE FIGHTING ENGINEERS
plants for our army in France. A force of 200,000 trained, skilled mechanics had to be recruited for this work. The cost of the operations, — about $187,000,000, — is more than three times the annual outlay in build- ing the Panama Canal.
The work progressed with military pre- cision at an unheard-of rate. The sites of the sixteen National Army cantonments were not approved until dates ranging from May 31, to June zy, 191 7, but the contracts were issued, nevertheless, between June 15 and June 23, and work was commenced be- tween June 1 3 and July 6. In less than three months, or on September 4, half a million men could have been accommodated at the cantonments. By December the camps were practically completed.
The total area of the cantonments is 261 square miles. In these camps alone over 800,000,000 feet of lumber were used, or enough to fill 37,000 cars, and 40,000 more cars were required to bring the other ma- terials, making a total of 77,000 cars. Some idea of the magnitude of the task may be gained from the fact that 172,000 doors were 190
AMERICAN VERSATILITY
used, 34,000,000 square feet of wall-board, 106,000 kegs of nails, 314,000 barrels of ce- ment, 282 miles of pipe, 23,550 hydrants, and 75 miles of fire-hose. The building of these great wooden cities has been a unique achievement, one that will go down in history as a monument to the loyalty and ability of American engineers.
Preparations on this side of the Atlantic for expediting the delivery of war supplies are most impressive. A vast system of in- terior depots and port-terminals has been de- signed, which doubtless establishes a new standard of efficiency. Under the direction of the cantonment division of the quarter- master-general's office, a large force of de- signers perfected plans on an enormous scale. The type of construction was selected with an idea of early completion, although most of the buildings will be permanent and will be used by our Government after the war.
A series of interior depots of great ca- pacity were first designed at points readily accessible by railroad to the large manufac- turing centers. In connection with these, a number of port-terminals have been located 191
THE FIGHTING ENGINEERS
at tidewater, where ocean-going vessels might dock, or, at least, be within lighterage distance. The products of the factories are first assembled in the interior depots by rail- road or motor-truck. These depots thus come to form great reservoirs for feeding the terminal warehouses. An enormous vol- ume of supplies can thus be moved from the interior of the United States to the coast, and finally to France, with the least possible delay.
Interior depots have been built at St. Louis, Chicago, Pittsburgh, and elsewhere convenient to the great manufacturing cen- ters. The type of buildings varies with dif- ferent localities, some being constructed of reinforced concrete, while others are entirely of steel. The first of the great port-termi- nals was erected at Philadelphia. One of these terminals occupies a tract of land 3800 feet in length, along a ship-canal that has a depth of 25 feet and a length of 1600 feet. Special tracks have been laid, connecting the terminal with a main-line railroad half a mile away. Along the sides of the canal two open sheds have been constructed, measuring 192
AMERICAN VERSATILITY
1 100 by 1 60 feet, nine large storehouses, an open shed 1200 by 500 feet, together with quarters for the stevedore troops. A series of warehouses have also been built 160 feet in width, in multiples of 140 feet in length. Another of the great port-terminals has a pier extending 1500 feet, and utilizes 400,000 square feet of shed-storage.
In organizing our resources, an important use has been found for the skill of the moving-picture men. It is well known, of course, that a large proportion of the mov- ing-pictures used the world over are made in America. A large force of men has thus been trained in the new art, and, as might be expected, this group has reached a high state of efficiency. The Government has added to its engineering regiments hundreds of men recruited from ''movie" studios to assist in preparing camouflage material. Every fre- quenter of moving-picture theaters knows that these artists perform wonders in build- ing villages or the semblance of cities over night. In a few hours they can produce scenes from any country or century so con- vincing in every detail that the most critical 193
THE FIGHTING ENGINEERS
moving-picture audience is readily deceived. It has been a happy idea to utihze this skill in safeguarding our armies abroad. The ingenuity displayed and the amazing facility of these war artists in their work may well be a source of pride to Americans. Work- ing with lath and canvas or papier-mache, the magic of the movies has been adapted to many surprising uses. After long expe- rience in building scenes that deceive mil- lions of "movie fans," it is an easy task for them to produce the same illusion for Ger- man military audiences. One of the most successful ''sets" is a reproduction of de- vastated buildings in the war zone. It often happens that a fragment of a house or a church, perhaps only the corner of a wall, is left standing in no-man's land. The camouflage artists quickly reproduce the piece in life size with light wood or papier- mache, and then paint it to duplicate the original. On some dark night, perhaps un- der cover of artillery fire, the original ruin is removed and the duplicate set up in its place. A day or two is allowed for the enemy to detect the deception. If the for- 194
AMERICAN VERSATILITY
gery passes muster, it is cautiously moved forward a few feet every night. It is often found possil)lc to advance the piece of scen- ery a consideraljle distance nearer the en- emy's Hnes without arousing suspicion. Meanwhile, an alert scout from a look-out at the top of the fake ruin spies upon the enemy and by means of telephone communication keeps his base supplied with information. A similar deception is often worked by keep- ing the ruin stationary, but to increase its height a few inches at a time until the in- genious observation-post reaches the desired elevation. Thus it becomes a matter of life and death as to how skilfully the scene- painter can practice his art.
A piece of landscape having a thousand details to deceive the eye is sometimes repro- duced with perfect success. At one point on the long battle-line a road chanced to cross both trenches at right angles, so that the enemy could look for some distance up this thoroughfare. An elaborate piece of stag- ing was prepared to reproduce this scene, and this was set up one night across the road. Viewed from a short distance, the 195
THE FIGHTING ENGINEERS
enemy imagined that he still looked up the empty road. The painted scenery mean- while concealed the actual road, which was quickly utilized by trains of automobiles bringing supplies and ammunition. This surprising activity went on for several weeks, until a chance shot destroyed the scenery across the road and revealed a very different picture to the amazed Germans.
Every object found on the battle-field is reproduced by these skilful stage-artists to serve some purpose. When the ground is apparently absolutely barren, some means will still be found to deceive the enemy. A stone, a log, or some piece of debris will be selected and carefully reproduced. Under cover of darkness the stone, or whatever it may be, is removed and the imitation put in its place. A day or two is given the enemy to discover the forgery. If he does not, a hole will then be hollowed out beneath the stone large enough to conceal a man, and here he may sit with his head covered by the piece of stage scenery. He must take up this perilous position at night, and remain there until the following night, but if he sur-
196
AMERICAN VERSATILITY
vives, he may be able to telephone back some highly valuable information. One of the favorite ''properties" of this kind is a repro- duction of a dead horse, with distended body and stiff legs pointed upward. The ob- server thus protected has an unusual amount of room in which to turn about and to op- erate his telephone.
Years are required for an industrial, peace-loving people to recruit and train a great army. Brought face to face with the forces of a distinctively military people, the United States is, of course, for the moment at a great disadvantage. Her great army of engineers, with its innumerable conquests in every field behind it, has, however, been mobilized in force at a moment's notice.
The American engineer is in no sense a superman. He has brought average skill to his work with perhaps a liberal share of American energy and alertness. His ver- satility is due to the simple fact that he has been trained in the greatest school of expe- rience in the world. He has encountered every conceivable engineering problem in the United States, and with these achieve- 197
THE FIGHTING ENGINEERS
ments behind him, he is well prepared for any new undertaking. A New York fire- man, for instance, enjoys a reputation for skill, not because he is more alert or more intelligent than the firemen in small com- munities, but because he fights half-a-dozen fires of all kinds every day.>^
In the early days of the war, when Atlan- tic steamers were crowded to capacity with home-coming Americans, a number of en- gineers were already bound in the opposite direction. Mr. William J. Hillgas, the well- known engineer, was one of the first five to reach the front, and he has since been ac- tively employed in France. One of the first American engineers to join our forces was Mr. (now Major) William Barclay Parsons, who, it will be remembered, was the chief engineer of the Rapid Transit Commission who directed the building of New York's first subway. The foreign staff to-day in- cludes Mr. W. S. Buck, who built the Man- hattan Bridge across the East River and one of the great Niagara bridges. The engi- neer who built the East River Tunnel is also 198
AMERICAN VERSATILITY
in France. The list might be continued in- definitely.
A force of American sanitary engi- neers has been entrusted with the work of cleaning up Palestine. Since the days of the Roman occupation at least, the sanitary situ- ation throughout the Holy Lands has been a constant menace. Jerusalem with a popu- lation of lOOjCXX) has had no water supply and no sewage system. Throughout Pales- tine the better classes have been obliged to import their drinking water from Austria. The system of drainage has remained ex- tremely primitive. It is necessary to edu- cate the public in the most fundamental prin- ciples of sanitation.
A new era will be opened for the Iloly Lands w^ith the adoption of modern Amer- ican methods. Our engineers have taken with them, for instance, a complete filter sys- tem with a special chlorinator apparatus which will make it possible to supply thou- sands of the population of the region, wnth pure water. It is planned to supply at least two gallons a day for every person. For the 199
THE FIGHTING ENGINEERS
first time in recorded history the Holy Lands will be made a decent place to live in.
The American forces will be directed by several of the best known sanitary engineers of the country, including Captain Groemiger, President of the American Society of Sani- tary Engineers, Captain Pease of the Wor- cester Polytechnic Institute, Captain Carson, Chairman of the Research Committee of the American Society of Sanitary Engineers and others. The work of the American engi- neers will include the scientific drainage of great areas of swamp regions to insure per- manent relief from the menace of disease. It has remained for American ingenuity and energy to utilize the pools of Solomon to purify its historic waters by modern meth- ods, and make it available for the capital of Judea. In lending the genius of its engi- neers, America is making a contribution worthy of our country's best traditions.
200
"LADIES FROM HELL"
By R. D. PiNKERTON
This is war — its thrills, its nobilities, its splendors. A poet at heart, and face to face with the flaming realities, this young Scotchman wrote the first draught of his book, and in it is the very breath of the battlefield.
Mr. Pinkerton was a member of the famous London Scottish Regi- ment, which went into the fighting at the very beginning. "Ladies from Hell" the Germans called the Scotchmen in kilts as they came tearing through their lines, fighting with an effect associated with a place whose climate is said to be different from that of Scotland ; and the name has lived.
The reader will re-live, with the author, in minutest detail, his months of training and fighting; the reader will be made a comrade in arms with the captivating "Ladies from Hell." From the book Americans may see, with a clearness to be gained from few other books on the war, just what our soldiers meet when they fight the men in the dirt-colored uniforms.
There are in this book of a fighting Scot with a poet's heart flashes that tremble in vividness against the tremendous black background. And at the end the reader will know more of what war is — its sacrifice and its magnificence — than he ever knew before, unless he already has been at the middle of the greatest event of modern times.
Illustrated from photographs Price $1.50
At All Bookstores TUC PFISITITRY CC\ 353 Fourth Avenue Published by * HE VEiil 1 UIV 1 \AJ. New York City
FLASHES FROM THE FRONT
By Charles H. Grasty
With a Foreword by General John J. Pershing
"The history of this war cannot be written without the perspective which time alone can give," says General John J. Pershing in his foreword. "In the meanwhile such chronicles as the author (Mr. Grasty) has pre- sented supply the public with current information and preserve a useful record for the historian. The exceptional opportunities of observation enjoyed by the author will make this volume one of the best among contemporary publications on the war."
Mr. Grasty is a war correspondent of the New York Times traveling with orders to go wherever there are big things to see, study and write about. "The exceptional opportunities of observation" spoken of by General Pershing are founded on the international prestige of his paper, the machinery for facilitating the seeing and reporting put at his disposal by its regular correspondents in Europe wherever he went, and Mr. Grasty's own special equipment for seeing and studying the great figures and events of the war.
"Flashes From the Front" is made up of his maturest opinions on men and things of the war, and they are presented with an accuracy, charm and fullness not possible for the usual newspaper correspondence. The book is a series of brilliant sidelights on the war, illuminating now an outstanding figure among the Allies, now a section of trench-Hfe, now a matter of diplomacy or international politics, etc.
"Flashes From the Front" is the cream of the material gathered in Europe by one of the greatest war correspondents from this side of the Atlantic.
Octavo, 350 pages
Illustrated with photographs, and with drawings
by Muirhead Bone, one of the official
artists for the British Government
Price $2.00
At All Bookstores TII17 rTWTITPV CCi 353 Fourth Avenue Published by inEi V/EilliUIVI \^\I. New York City
THE ROOTS OF THE WAR
By William Stearns Davis
In Collaboration with William Anderson and Mason W. Tyler
This book undertakes to outline the circumstances that made possible Germany's inconceivably daring attempt to achieve at one, or, at most, two or three ruthless and gigantic strokes of the sword, the establishment of a world empire, an Empire of Teutonia, indescribably vaster, richer, more universal than that of imperial Rome.
President Wilson, himself a historian, has said: "You can explain most wars very simply, but the explanation of this war is not so simple. Its roots run deep into all the obscure soils of history."
It is to discover some of these roots and their fateful growths that this book was written. It covers especially the period from 1870 to 1914, with background references of course to preceding European history.
The authors say in their preface : "By general consent the period of history which ended in 1914 saw its beginning in 1870 when the Prussian militarists won their original triumph over France, thereby establishing a precedent for the use of armed force as a wise supplement to flagging diplomacy, a precedent that was to be applied with incalculable effect upon a much greater field of action forty-four years later. During this interval a great many national and international forces were acting simultaneously which all together helped to produce the climax of Armageddon."
12mo, 400 pages f 6 maps Price $1,50
At All Bookstores TOC PpKITITPY CC\ 353 Fourth Avenue Published by * "Ei V/Eiil 1 UIV I \AJ* New York City
THE AIR MAN
His Conquests in Peace and War
By Francis A. Collins
Author of " The Camera Man," Etc
In these stirring times when newspapers almost daily carry some thrilling account of a battle amid the clouds, a book like "The Air Man," by Francis A. Collins, cannot fail to interest a host of readers. Here, in succinct, vivid style that is not too technical for the lay mind yet never departs from a clear exposition of its subject, the author paints a picture of the immense strides — or shall one say flights — that aviation has made since the Wright brothers introduced it to the world.
There are chapters on training the tyro and the qualifications, physical as well as mental, necessary to become an expert; the art of navigation and the recently devised mechanical arts that render it a practical cer- tainty; types of aeroplanes, their cost and up-keep, together with records of flights in this country and abroad ; methods of use, such as for hunting, exploring, business, pleasure or war, giving graphic illustrations in each case; the progress of aviation in the Great War, with its remarkable but inspiring code, the "Chivalry of the Air"; and, last but not least, the gratifying record of American achievement in aerial scouting work during the Mexican campaign.
All in all, this is a book that holds the attention, and makes the heart beat faster ; it will have a tremendous appeal for aroused America — ^young and old.
12mo, 300 pages.
Fully illustrated from photographs
Price $1.30 net
At All Bookstores TUC rFNTITPV C(\ 353 Fourth Avenue Published by * HE. V/Eiil i UIV I \AJ, New York City
THE CAMERA MAN
His Adventures in Many Fields: With Practical Suggestions for the Amateur
By Francis A. Collins
Author of "The Wireless Man," etc
A fact-story that reads like romance, telling what men can do, what men are doing every day, with the black box with the unprejudiced eye. A book full of entertainment and information for the general reader interested in adventure and popular science and of very special value for the amateur photographer, to whom it offers many ideas for the enriching of his experiences with the camera.
Most people do not realize what a large and important work the camera does to-day, into how many and what various spheres of activity it has been called. Mr. Collins knows his subject intimately, and he presents it with simplicity, completeness, and charm as well as with scrupulous accuracy.
The following, which are some of the chapter-headings, indicate the scope and nature of the book: Aeroplane Photography; The Camera Man at Sea; The "Movie" Reporter; The News Photographer; The "Movies" in Warfare; The Commercial Photographer; History of the Camera; Color Photography; Photography in Science; Many Kinds of Cameras.
12mo, 325 pages, jacket in color
32 full-page illustrations
Price $1.30 net
At All Bookstores TUC ri7WTITDV CC\ 353 Fourth Avenue Published by inL LLillUlVl KA). New York City
DONALD THOMPSON IN RUSSIA
By Donald Thompson
This book constitutes an amazing, contemporary, eye-witness record of Russia in revolution by an American who had to be in the midst of the cataclysm and who was interested only in seeing the facts.
Donald Thompson went to Russia to photograph the revolution. "Shoot the revolution" is the phrase, for he made thousands of feet of moving-picture films. You cannot imagine pictures, or get them from some person who heard from a friend that so-and-so had happened ; you have to be on the spot in the midst of things to get photos and "footage."
Donald Thompson was in the midst of the Russian revolution. He went everywhere, favored by luck, supported by a camera experience on every front in Europe that is without parallel. E. Alexander Powell, the famous newspaper correspondent, says in his book, "Fighting in Flanders" : "Of all the band of adventurous characters who were drawn to the Con- tinent in the outbreak of war as iron filings are attracted by a magnet, I doubt if there was a more picturesque character than a little photographer from Kansas named Donald Thompson. ... He not only saw war, all military prohibitions to the contrary, but he actually photographed it."
When Mr. Thompson started for Russia, to fall into the biggest story he had ever dreamed of, he began writing newsy, vivid letters to his wife. As he penetrated more deeply into the thrilling events in Russia, he found himself telling the story of the Russian revolution, in detail, as he saw it, as it happened.
8vo, 300 pages, 64 illustrationa from pnotographs Price $2.00
At All Bookstores TUF rTMTITDV Cfi 353 Fourth Avenue Published by 1 nL LLIN 1 UK I lAJ. New York City
UNIVERSITY OF CALIFORNIA AT LOS ANGELES
THE UNIVERSITY LIBRARY This book is DUE on the last date stamped below
IAP:<
iWAi
18
"tfr^KL
laBD
^14
:■< i
^\>
^^^^
^^
CO
KPR27'73
0
"Bffl^
SE DEC 20 1989
1373 impa uum
291975
20m-12,'3n(.'i;iSG)
nStTERSm OF CALIFOSSXi
AT LOS ANGELES
570. S Collins - C69f _The_fi£htij engineers.
L 005 834 339 3
UCSOUTHFRN l«:,r. •,.■.! , :l'!J-l.:, ;; ilJTY
AA 000 785 856
'^rr
Jfii *:-*y.\
.\M.£-''^
.; :. -sw^
'' Mi. V' m 'k ii "*./
•^yl^^w'^-^>.
'^^'^^ittf^^''^^^^^^^^^^
\5^ «^
d'*'^.MCjtX>*''
«, #. -f. 'w tel m«9' ■«
il:Ci
^l It . ^
,r"'^:-"t^'
^ « -fti -ji^ #
I*^"**
i.^^s- .- j^.,....^
-*-^ i: A 'C-'*, -i^
|
d vi |
(^r
-F""
^:
».a,
[l '^^
■ ■■«
i'^ f
♦ Cv
•^1 I