SB 608
05 K4
Copy 1

Bulletin No. 11-N.

SPRAYING WITH “BLACK LEAF 40”
TO CONTROL ONION THRIPS.

(Original)
Practical method of spraying onions with a barrel sprayer.

The Kentucky Tobacco Product Company

Incorporated

EQUISVILLE,. KY U.S.A:

Copyrighted 1916, by The Kentucky Tobacco Product Co., Incorporated.

Spraying with ‘Black Leaf 40° for the Control
of the Onion Thrips.

Onions, in common with other truck crops, often ‘‘fail.’’ Such ‘‘failures’’
were at one time considered ‘“‘natural’”’ and a matter of course. It was thought
that nothing could be done to avoid the injury and if the crop did “‘fail’’, the only
thing left for the grower was to hope for better luck next time. This condition is
rapidly disappearing. Progressive growers now realize that each failure is due
to certain definite causes, some of which are preventable.

A considerable proportion of such failures is caused by the onion thrips,
known as ‘‘onion louse,’’ a small, narrow, active insect. When young, it is light
yellow and is generally found deep in the fork of the onion plant. When it becomes
a fully developed, winged insect, it is darker and is found on the leaf of the plant
as well as in the fork.

HABITS OF THE ONION THRIPS:

This very small insect lays its eggs just beneath the surface of the leaves or
stem. It usually takes two to three weeks from the time the eggs hatch until
the developing insects themselves lay eggs, but cooler weather may lengthen
this period. These thrips continue to multiply as long as the weather and food
permit. From these facts it is evident that though few thrips are present at
any one time, they may occur in destructive numbers later.

The onion thrips feeds on a large variety of garden, field and ornamental
plants, the most common being cabbage, turnip, cauliflower, cantaloupe, melon,
squash, cucumber and tomato.

THRIPS INJURY TO THE PLANT:

The grower first notices a “‘silvering’’ of the onion tops. Upon examination
he discovers this silvering to be due to scratches on the leaves caused ie the
thrips. Growers frequently call this condition ‘‘white blight.”

The next evidence is the curling, twisting and drying of the leaves, their
color changing to brown. In fact, a badly infested field may look as if the tops
had been entirely burned over. The crop may be so injured as to amount to
_total destruction; or the bulbs may be so reduced in size as to be hardly worth

_ -pulling. A sudden hot or cold spell finds injured plants unprepared to withstand

» the change, often resulting in considerable additional injury.

METHODS OF CONTROL.

The directions here given are based on actual control work conducted on
commercial onion plantings. The control of the onion thrips is practical, economical
and profitable. Follow the directions given in this bulletin, do the work thoroughly
and faithfully and your efforts will be well 3 while.

JUN 13 1916 @cia434443
Ub (

FORMULA:*

“Black Leaf 40’’____5 fluid ounces (a little over }-pint).
Waterss 212 eee ve Se 50 gallons.
Sodpet ses: - eases = 3 to 4 pounds.

The larger amount of soap is to be used where the water is hard. Note par-
ticularly that enough soap should be present to produce suds.

To dissolve the soap, slice it thin and boil it in a small amount of water. Keep stirring.
Cotton seed oil soap or any good laundry soap will do, provided it is not caustic. Soft soap is
even more preferable, as it dissolves more readily. The soap is used as a ‘‘spreader’’ to enable
the “Black Leaf 40’’ to penetrate into the fork, cover the plants and to prevent the formation of
drops which may roll off and leave the plant and insects dry.

“BLACK LEAF 40”:

Is a concentrated solution of nicotine sulphate guaranteed to contain 40%
nicotine by weight. It kills thrips and similar insects when brought into contact
with their bodies. Being highly concentrated, it is easy to handle and ship and
requires very little room for storage. A two-pound tin makes over 250 gallons
of spray for the onion thrips. Mixing readily with water, ‘‘Black Leaf 40” does
not clog spray nozzles, nor does it injure foliage when used as recommended.

“Black Leaf 40’? has been widely tested. The directions are based on the
recommendations of the United States Department of Agriculture and State
Experiment Stations, in addition to other field experiments.

In the report of Insects Injurious to the Onion Crop, which appeared in the
Year Book of the U. 8. Department of Agriculture for 1912, occurs the following
statement, on page 324:

‘Plants sprayed with nicotine sulphate combination present a striking
contrast to those which are not so treated. In Maryland, near the District.
of Columbia, a single spraying of nicotine sulphate gave similar results,
the plants doing better and the insects being killed to a larger extent than
by the use of other insecticides. Kerosene emulsion has sometimes proved
a failure in Colorado and elsewhere and is, moreover, difficult to make with
hard or alkaline water.”’

WHEN TO SPRAY:
Start Your Campaign as Soon as Possible.

Do not delay until the onion tops begin to turn brown. It may then be too
late. Whena grower states that he lost his crop, ‘‘all ina few days,’’ it is evidence
that the thrips have been in his field ali season.

Here are some of the reasons why the spraying should be done early.

The earlier you spray the less time it takes to cover an acre.

The earlier you spray, the less material is necessary per acre; later,
as the plants become larger, more spraying material is needed.

The earlier you spray, the easier it is to hit the insects. Later, when the
tops are large and bent over, it is much more difficult to reach them with the
spray.

The earlier you spray, the fewer insects there are to control. For every
insect present early in the season, later there may be hundreds or thousands.
Destruction of the ancestors would prevent development of the descendants.

* Good results have been obtained with 4 ounces ‘‘Black Leaf 40’’ to 50 gallons.
3

SPRAYING CAMPAIGN SHOULD BEGIN IN THE SEED BED:

Many serious: attacks in commercial onion fields may be traced back to the
seed bed. If you are growing your own plants, see that the thrips are con-
trolled in the seed bed. It may be advisable to spray several times at intervals
of seven to ten days.

BEFORE TRANSPLANTING:

Before transplanting, dip the plants in the same formula as used in spraying.
The U. S. Department of Agriculture recommends dipping about a week before
planting time, and then dipping twice at planting time. Many thrips are brought
into the fields on the transplants. An ordinary bucket may be used, the sets
placed in a wire basket, dipped, and allowed to drain.

IN SPRAYING ONION FIELDS:

Don’t forget that although spraying prevents considerable injury, it
can not remove injury after it has occurred.

Don’t experiment with unknown or untried material.
Don’t expect one application to clean up your field; make at least three.

Don’t fail to spray thoroughly and with good pressure (not less than 150
pounds).

Remember, you must force the spray down between the leaves.

Don’t wait until the green tops begin to die and then expect to save the
crop. Spraying will pay at this time and may save part of the crop, but the
best results follow earlier applications.

Don’t forget that you can control the thrips in young onions more effect-
ively and more economically than later in grown plants.

REMARKS ON EQUIPMENT:

For a small bed, such as the kitchen garden, etc., of very young onions, a knap-
sack or small compressed air sprayer may be satisfactory. However, we recom-
mend, especially for large beds, the use of an outfit sufficient to develop good
pressure. In the seed bed and on young onions, satisfactory results may be
obtained with a wheelbarrow-tractor wherein the wheel works the pump, or a
handcart sprayer, which is an ordinary metal tank holding a good hand pump,
mounted on a two-wheel handcart.

In young onions, both the wheelbarrow and handcart sprayer can be guided
between the rows without difficulty and without damage. In using outfits of
this kind, the nozzles should be adjusted so that when the outfit is in operation,
the nozzle will be but slightly above the top of the plants. These small outfits
develop much less pressure than the larger outfits, hence full advantage should
be taken of what pressure is developed, and this is obtained by keeping the nozzle
as near the plant as possible.

4

(Original)
Spraying very young onions with a wheel barrow-tractor sprayer.

The wheelbarrow-tractor outfit should not have more than two nozzles,
one on each side of the outfit. Eash nozzle should cover only one row. More
than two nozzles may be put on the handcart outfit, if the pump is sufficient for
maintaining a good pressure for each nozzle. ‘

The above outfits may be found useful for young to half-grown onions; however,
even for young onions, the barrel (preferably a double action pump capable of
maintaining 150 pounds pressure), or a power outfit will give the best results;
and these outfits are absolutely essential for effective work on older onions. The
small outfits with fixed nozzles do not develop enough pressure to drive the spray
into the fork of the older plants.

THE BEST TYPE OF OUTFIT:

Use a good barrel or power outfit with a long hose which, if necessary, may be
as long as 100 feet or more. The hose is equipped with an extension rod (such as
is used in orchard spraying), about 12 feet long, with a Bordeaux or wide angle
dise nozzle attached. The man doing the spraying walks down one row and swings
the rod across the rows in front of him, spraying first one side as far as the rod
will reach and then the other; in this way covering a swath about twenty-five
feet in width. It may be necessary to have a man at the outfit to play out and
pull in the hose, as the man handling the spray rod goes out or comes back, (see
illustration on page one). It is possible, in many plantings, to spray the whole
bed without being obliged to haul the spray machine over it, by having a length
of hose half the length of the onion rows. In such case, half the length of the
rows is sprayed from one side, then the outfit moves to the opposite side of the
field from where the other half of the field is sprayed in the same manner.
Where onion rows are too long, it may be necessary to make an extra trip through
the field in order to cover the full length of the rows. In such case, there may
be a slight amount of trampling unless a lane for the outfit has previously been
provided for. ,

5

Using a power outfit with boom attached for onion spraying.
For this photograph, the nozzle was held high to show spray. In actual work the
nozzle should, of course, be held much closer to the plants.

Good results have been obtained by using an ordinary power orchard sprayer
with a boom attachment on each side extending perhaps twenty feet on each side.
At the end of this boom, attach about fifteen feet of hose and extension rod—the
longer the better. With an equipment of this kind on each side of the machine,
each outfit can spray a swath of from 70 to 90 feet by driving through the field.
The spraying is done across the rows by a man on each side. Each man works
away from the outfit as far as the hose and boom will permit and then works in
toward the outfit. (See illustration above).

The nozzles should discharge the spray at right angles to the rod, so that
there is a direct spray downward, as the rod is held horizontaliy. The nozzle
should be swept close down across each row and should occasionally be turned
so that the plants will also get a discharge of spray on the side, in addition to the
regular spray into the fork of the plant. It may be found advantageous to have
two wide angle nozzles, one pointing down and forward, and the other down and
backward, by which arrangement all sides of the plants receive an application of
spray.

NUMBER OF APPLICATIONS:

Though good results may follow one or two applications; it is frequently
essential to have not less than three. Apply every week or two, depending on
the weather. More applications will be required in hot than in cold weather.
One application will kill all the thrips the spray hits and wets. But remember that
more thrips will hatch later and another application must be made to get the
following generation and those individuals that were not hit the previous time.

SPECIAL ANNOUNCEMENT.

The Kentucky Tobacco Product Company maintains a Field Department of
trainedentomologists. Submit your problems tothem. In the matter of planning
campaigns with individual growers, communities, organizations, County Agents,
etc., assistance will be gladly given.

TABLE OF DILUTION FOR ONION THRIPS.

‘Black Leaf 40”’ Water.
ND OUb ete ASPOONKU) Pee 4. & TS Sakae eee Male Te vee We eee 1 gallon.
ieAiudeounces(Sismalily teas O Oni ls) pee eee ee ee eee ee 12 gallons.
PPA OUNGCeSss( PINt) 222s & a ee See eee ree Oe Be Se 25 gallons
akon! oyitaverersy (Gy Ihre Cyicere pejoyuonn)) oe tee eee ee eae 50 gallons.
10 fluid ounces (a little over } pint).----_______--- Seed ange it tia ined 100 gallons.

PRICES OF “BLACK LEAF 40”.

10-pound tin, makes 1280 gallons of spray, $10.7:

2-pound tin, makes 256 gallons of spray, 2.50
t_yound tin, makes 64 gallons of spray, SUS
9-~

a0

l-oz. bottle, makes 8 gallons of spray,

PUBLISHED BY
TA MEN UGTIY: TOBACCO; EPRODUCH COMPANY?
Incorporated
LOUISVILLE, KENTUCKY, U. S; A.
Manufacturers of ‘‘Black Leaf 40.”
Form 219. 1—16-6.

Ww

Aen :
ica